Video

Thanks guys how funny my MY18 Colorado is bringing looked at tomorrow by someone i won't say but on the Northern Beachers Sydney haha for the same problem only done 77 thousand great video

OK so I get this straight. I can use this lockup on the highway, downhill and manual shifting for engine braking but not everyday driving.

3 transmissions on my 2001 Dodge diesel truck burnt up before 2nd transmission shop found oil cooler was plugged up. Hopefully the 4th transmission lasts longer with the new oil cooler installed.

Amazing Job! Would this conversion be applicable to an ex-army 1991 Land Rover 110 Perentie 6x6?

I just installed mine yesterday 20 2019 ranger with65K on clock, what a massive difference, i have already fitted the bypass valve few years back, and my trans ran from 94-97 degrees, yesterday the ambient temp was 19 degrees, and now the trans oil only got to 55 degrees after driving for 30 minutes, i suspect in summer it would probable go 20-25 degrees hotter which would put it at 75-80 degrees is my guess, never the less very happy with the result, :)

great video. Will assume the bypass valve does exactly that. Did not hear if there is any thermal activation or if system is totally free flow. You could tell your video editor the music is totally unecessary (and irritatingly loud). Anyone who's going to sit through a 23 min vido on how to RnR a tranny cooler isn't looking to listen to high low music IMO. Thanks for the video

Oil samples are a great tool.

Wish you guys were here in the U.S I'd be on the way to see guys. You obviously know what you are talking about. I have a 17 Colorado with a 2.8 liter diesel in it. Love the truck minus the transmission. I've had the same issues when towing with it. The shudder and at one point a millisecond lock up in tow haul mode going up hill. As soon as the transmission gets warm from towing it all starts. Shifts really smooth if your not towing and just normal driving but when you start working the transmission it all comes back. Took it to the dealer and had the thing flushed out and a TCM update but it all came back. Initially it started just driving it around while not towing anything. Thought it was all cured until I started towing with it after that. Like I said it all came back and worse. Anyway great video. Wish I knew of someone here in the states I could take it to with your knowledge.

Hi Orto, what would i expect to pay for such a job?

Wow 😮

You say that you’d be mad not to change the starter motor while you’re there and I agree but it seems strange that you would say, you’re going to keep the one that you’re pulling out, just in case you need it. That statement is counter intuitive, surely because if you did that job again (if you had starter motor problems) surely you wouldn’t be putting your old one back in?

Beauty

Whats the recommended fluid change interval for this transmission. Excellent video guys

The prado install looks like a real pain in the butt

Buses use these instead of clutches most of the time, thank you for the explanation

Hey mate thanks for the vid. I am having your full kit fitted to my PX2 Ranger in two weeks next door to you guys as I left the booking way too late and you are all booked out anyway I done an 8 month trip of Tassie last year April to December towing our caravan all over the isle and the Ranger was working very very hard at times especially in the West I often wondered weather the transmission would hold up which it did without me knowing if it too indeed struggled. we are heading off to the Cape early August towing the caravan leaving it with friends in Cairns then off to do the Telegraph track and on return to Melbourne heading West to Darwin then down the middle and back home I would say this is the time the cooler will truly come very handy. You totally rebuilt my son Frank Jr's PX2 Silver Ranger not that long ago.Any extended away trips in the pipeline?

Interesting: I have a relative with one in Trinidad and the company stated it was a torque converter issue. Changed and over time, it did the same. He had it to a specialist who changes dome valve body components, among other things I can't recall. But what I was wondering is, many of the US users in forums stated the issue came down to the dexron6 ATF the company uses and by using a specific one (Mobil 1 HLVP) it stopped the shudder. I can't explain it.

can i convert my kia rio 2013 to automatic transmission

Awesome video, especially liked the vacuum test, thanks

You have a link for this cooler?

How can I get one for my 2020 ford ranger I live in Florida USA

I have a Ranger. In fact I have two. Both are 2021 Tremors with the 1080R tranny. One of the is as smooth as anything. The other has actually downshifted twice from 10th gear to 6th and has a problem with acceleration and harsh shifting. Shutters and clunky downshifting. I’ve had it in several times and they say there is nothing wrong and proceed to reset the TSB. I’m being completely ignored. Any advice as to what can be done? It’s obvious it shifts poorly but since it has not thrown a code, they cannot fault anything wrong. What can be done? It’s still under warranty with 25k. Great video and thank you for taking the time to share it with us. Cheers

Thank you. The Vaseline holding the springs was a good trick. I didn't know how I would do it by myself.

When the valve in the front pump fails can this be picked up when they look at pressures with the diagnostic tool?

Love the product but does it effect the radiator efficiency since you are blocking most of the radiator?

What would a reconditioned box cost , with the mods

Watching from the states, amazing video and explanation on the 6L50! Great for consumers to be guided through these complexities.

Is there another location for the heat exchanger that doesn't block off the factory radiator?

hi do you offer any service for the middle east Dubai, we are so far , there is a big over landing community i have a A750F on lc200 used for over landing would love a nomad valve body but sending one back would cost so much

Excellent 👌👍

A442f 1993 Landcruiser..cheers

excelente

Can't i get convert to 6 speed automatic for 2008 puma 2.4 Defender 110?

Hello, I am the owner of an Isuzu d-max 2020. My question is whether I can buy this cooling kit from you and what is its price. I'm from Poland

Unfortunately, most engine/trans gauges were replaced with warning lights, gauges are better, you can see whats going on, by the time a warning light comes on, the temp is already dangerously high or pressure is dangerously low.

Hi mate great video. I've started hooking into mine question brains trust so the hoses that go to the unions on the transmission is there a left and right sequence ?

I just watched a video from a Perth CZcamsr with a new v6 Ranger who you supplied the cooler kit for, what sort of temps reduction would you hope for after installing the kit? im not sure if he has done something wrong with the install as it appears from his before and after tests using his scangauge ll that he went from running a ,max of 100' and dropped after installing the kit to a max of 93' he showed his average temps before were high 80's to low 90's and after the kit the average driving temps only went down by 4-6' is that normal? i would of expected a bigger drop in temps? has he done something wrong?

Great video yes pls more customers trucks.😊

I see it as manufacturers don't seem to care if the customer is aware of the constant changes in technology. They want you to buy the brand. If it stuffs up all that's on you.

A right-handed person wearing his watch on his right... proof that things indeed do run backwards in Australia. :))

the transmission oil line that you've cut, is that the line going back to the Transmission after the radiator?

you forget to reinstall the horn, may be?

Excelent video on what can go wrong and what needs to be fixed.

OK I watched your video I have a 1996 nk pajero 3.5L v6 dohc petrol 4 the last 18 years it has a factory oil cooler in it transmission has not been touched besides filter an pan flush and never had a problem. Now I have a prado 150 3L turbo diesel and I put a kaon transmission cool in it and have been concerned about running to cool . Anthony fourby4diesel CZcams hates them said could damage your transmission running to cool so now I'm big time confused but after saying that cooler is still on prado and have a great day.

I had my whole auto replaced because the clutch that does 3rd, 5th and reverse had shat itself, does that sound right guys.

Hi, I’ve seen very interesting information about transmission and I wanted to ask you on the brand of the transmission fluid. I have A 2022 Honda civic cvt transmission I do the service about every 22k. I always was told the best fluid is original oem from Honda but from what i looked into is that amsoil valvoline and Castrol give good results better than oem fluid Which would you pick to put in a cvt? I would appreciate it.

You made it look easy.well done

Link?

Can you please advise.. The new valve has longer landings has the corresponding bore where the new style valve goes into have the longer landings ?

Hi that was one of best informative easy to follow video I have seen thanks