Every good bike in that time frame had distinctive chain noise. It was a trend among manufacturers. Such distinctive noises reduced with time and today we have more engine noise over mechanical noises. Previous engines were dead silent on idle , hence other good mechanical noises and sounds were more audible. Alongwith Karizma R , Pulsar 180 & 220 had chain noise which was amusing while riding as well. Karizma had leaner tone to it , pulsars had heavier tones. Bikes like apache had it too , but less as compared to the other two.
35000 km driven without changing chain sprocket is insane. My chain sprocket has started that sound on 20000 planning to replace it before that i will apply this technique.
Maine to motul ka 7100 fully synthetic oil use kiya jo mere pas extra the but aap shaft ko grees se lube karsakte ho Maine waterproof grees use kiya hai uska video jaldi upload karunga.
This problem I'm FACING nowadays .. !!! Mechanic said my bike Chain is normal : No loosened or too tighten .. 🙄🤔 He just put some Lubes on it and give me Back with advising to clean it whenever it's get too Dirty. BUT ... Still that sounds started again. 😫😤😓 Tomorrow I will go again and check my Bike's CHAINS. Later i will update my comment and tell you My Bike's problem and solutions. It may Help you out whoever may facing same problem. 😊 🙏🏻
Meri average speed hai 50 city mai is se ziyada 10 second b nahi tik pate agar aap 80 or 100 plus ke upar hi chelate ho to silicon chain lube best honga.
10 days back changed my chain set in sp shine but same sound and rear chain sprocket is wobbling Service centre people suggested me to change back wheel assembly i have changed that also , bearings are also changed , can you tell me what is the main problem
There are something called damper rubbers in wheel where rear chain sproket fits did you changed that too ? I'd not check id the rear chain sproket is properly aligned.
@@MOTOMENTOR I have changed the damper rubbers at the time of installation of new chain set that is 10days back but 2days ago I again changed damper rubbers because they were broken only in 5days
There is not set schedule for lubrication you can lube as soon as you feel there is a need it depends how clean the chain is based in your surroundings... I do use clean engine oil some time to clean my chain.
@@BhatakantiEkPravas check chain adjustment zyada tight mt rkhwao clean the chain with diesel or cleaner then use chain spray. Also clean the front sprocket and after that open front sprocket and apply good quality grease on front sprocket spline. Do try this
Bro there is a bend in chain , some areas in loose and some place is tied. How to fix this issue, it's roll on brazz chain, new one I barely used 3k km . Pleae let me know
To be very frank I had the same issue with the stock chain which I used for 18k kms and post using the chain lube and not cleaning it timely got the same issue which you mentioned... I tried to soke it in kerosene and diseal bit no joy I had the get my chai replaced ... what kind of lube do you use for lubrication and how often you lubricate?
@@MOTOMENTOR aj kal gadi sab acche nhi reh rahe hain bro quality wise. Yamaha cost cutting karke bht degraded krchuka hai. Fzs product pura bigadchuke hain. Clutch repeat rubber ka issue toh 3000kms chalne k baad hi aagaya tha mere gadi men . bro isse pehle honda hornet160r tha . Bs4. Maine usse 3 shaal men 1.47lakhs kms chala lia tha .. kbhi b usme clutch cover bhi kholna nai pada tha . Aur koi b part nhi change hua tha. 1.4lakhs kilomtrs chalne k bad bhi koi issue nahi aya tha hornet men. Usse sel karke fzs lia tha.. yeh sochkr ki japanes gadi hai .bht last karega hornet jaise. But i was wrong . Bas ek chis acha hai. FZS ka fuel injection system. Koi isue nhi create karta kabhi .so durable. Apka kya point of views hai bhai??abt these brands
I agree with you infact in one of my video I have also mention about the new r15v3 clutch basket which k installed on my fsz the rubber of that clutch basket for faulty within 3k to 4k kms and I was shocked to see that... cost cutting ke chakkar mai ye log ne quality compromise ki hai .. mai b isi liys meri purani FZ abhi tak use kar raha hu coz is mai kaafi sare parts Japanese hai isiliye 13 years baad b ye tiki hai but hai abhi jo spare parts aarahe hai its not upto that mark. Sorry to say but ye logo jub se parts api country mai bana rahai hai quality kharab kardihai lekin kuch parts inke Indonesia aur Japan ke abhi tak aajatehai (galti se ) unki quality kafi aachi hoti hai.
@@MOTOMENTOR yes bhai! Sahi kaha apne . Apka jo old model hai fzs..ussi model se inspired hoke maine new version lia tha Fzs ka. Mera kabhi kabhi 950+kms ka b ride rehta hai .aur mostly 400km+ chalta hai ..(bht regret horhahai ab lene k bad FZS ) . Long route men jaane waale gadi men clutch ya phir engin related isue itne jaldi ane se bht bura feel hota hai bhai . Main rough b nhi chalata kBhi. Itne sab ke baad bhi agar issue aarha hai gadi men tab gadi ka manufacturing hi bekar hai .hadd se jyada . Bht regret karta hu hornet se new fzs men switch karke. Beech men itna irritated tha ki 600kms rides kuch baar maine apne 13years old activa se kia tha 3-4baar... fzs ko decorative piece jaise rakhdia tha garh pe.🥺 Ap lucky hain bhai apne sahi time pe lelia tha..old model .. Mere waale men mileage k alawa aur kuch better nhi hai. Sab chiz downgraded. Aur . Maine dekha hai apka r15 v3 wala clutch basket ka video fzs men.. aur uske bad jo apne sahi karwaya sound, clutch basket ke side wale pinnion change karwake .woh bhi maine dekha .. Bht help Mila mujhe apke video se bhai . Aur 3 oil change (2mahine k bad) men b wahi pinnion or clutch basket part change karwadunga. Ekdm se chalane nai hota gadi ab aur..jhatke pe jhatke deta hai bhid road men . I gues aj kal sabhi gadi bekar reh rhee hain . Quality issue ! Bikes se interest hi khatam hogaya hai ! Ab. 😔
@@MOTOMENTOR aur ek bada issue arise horaha hai new model fzs men ..(mere cousin ke gadi men hai)... Driving shaft jaldi khrab horha hai .. bas ussi ek part ko change karne ke lie full engine kholna padega abhi ..
Saste nashe mai nahi karta agar jhoot bolkar views lane hote to 4 saal se mai million subscribers hote. I make videos on my personal bike and based on my personal experience ... dad was 2 wheeler expert and worked in baja sice 1976 he knows a lot and shares most of the trick with me.... whats your views on this ... I can 100% guarantee a sproket set can last minimum of 50k if regularly lubed and maintain. I have friends who have clocked 60k without changing the sproket set .... a lot depends upon the quality of the product as well and how someone maintains it ... no offense but yes thats the truth and you will only appreciate once you experience it.
Thanks for this information, I will try this on my bike
Thanks bro 🙏
@@MOTOMENTORMay i know which oil you used here... please
Motul 7100 fully synthetic
I love my karizma r chain sound its very unique no other bikes dont have this sound..
I love Karizma bro the throttle response is just amazing the first time I drove it was more than a decade and I was just amazed with it.
Every good bike in that time frame had distinctive chain noise. It was a trend among manufacturers. Such distinctive noises reduced with time and today we have more engine noise over mechanical noises. Previous engines were dead silent on idle , hence other good mechanical noises and sounds were more audible. Alongwith Karizma R , Pulsar 180 & 220 had chain noise which was amusing while riding as well. Karizma had leaner tone to it , pulsars had heavier tones. Bikes like apache had it too , but less as compared to the other two.
35000 km driven without changing chain sprocket is insane. My chain sprocket has started that sound on 20000 planning to replace it before that i will apply this technique.
Bro duke 250 mei konsa oil use karna se hoga front sprocket mei Any idea?
thanks for sharing ❤
Use gear oil better than any engine oil
Yes full❤😊
Your tips always works
Thanks brother 🙏
I have a question, why the front spoket is smaller than the rear spoket?
Bst solutions ❤
Thanks.
you dont need to lube it as the lube from the chain lubes it anyway
gear soft andar bahar andar bahar ho raha hai kya kare...?
Thanks bro 🙏🙏🙏
Yw buddy 😀👍
Fzs ka all series bearing Leke video karo dada.
From Bangladesh.
Little slow in Hindi.
Bhai mere Fz 150 V3 mein bhi kuch gir girahat ki aise hi awaz arhi hai , smajh nahin arha dikkat kahan hai koi mechanic awaz nahi pakad paa rha
👌👍
Bro nhi gyii tk tk ki sound aa rhi hai chain set bhi change krvaa leye 2 pr 7 hzaar kilometre chlte hai oske baaad same situation ho rhi hai
❤❤
Thank you brother❤
Yw bro 😃👍
Bhai chain jump kaise theek kare ?
Uce engine bullet mein kaise kare usme to samne ka Spocket clean karne k lie rh cover open karna parega aur engine oil bhi drain karna hoga
Yes bro same problem
Bhai aapne front kis chiz se lub kra h kya isme greece ka bhi use kr skte h kya
Maine to motul ka 7100 fully synthetic oil use kiya jo mere pas extra the but aap shaft ko grees se lube karsakte ho Maine waterproof grees use kiya hai uska video jaldi upload karunga.
nine
Which lube you are using for lubricating?
gear oil
This problem I'm FACING nowadays .. !!!
Mechanic said my bike Chain is normal : No loosened or too tighten .. 🙄🤔
He just put some Lubes on it and give me Back with advising to clean it whenever it's get too Dirty. BUT ...
Still that sounds started again. 😫😤😓
Tomorrow I will go again and check my Bike's CHAINS.
Later i will update my comment and tell you My Bike's problem and solutions.
It may Help you out whoever may facing same problem.
😊
🙏🏻
Sure I also have a proper video on this made 2 years back check that too.
@@MOTOMENTOR OK 👍🏻
Bhai jab bike tez chalegi to centrifugal force ke karn sara oil bahar ki or uda dega fir!!????
Meri average speed hai 50 city mai is se ziyada 10 second b nahi tik pate agar aap 80 or 100 plus ke upar hi chelate ho to silicon chain lube best honga.
But that noise is good
How to do this in royal enfield
10 days back changed my chain set in sp shine but same sound and rear chain sprocket is wobbling
Service centre people suggested me to change back wheel assembly i have changed that also , bearings are also changed , can you tell me what is the main problem
There are something called damper rubbers in wheel where rear chain sproket fits did you changed that too ? I'd not check id the rear chain sproket is properly aligned.
@@MOTOMENTOR I have changed the damper rubbers at the time of installation of new chain set that is 10days back but 2days ago I again changed damper rubbers because they were broken only in 5days
How often should we do this lubrication?
Can we use car engine oil on the chain and sproket? Please reply brother 🙏
There is not set schedule for lubrication you can lube as soon as you feel there is a need it depends how clean the chain is based in your surroundings... I do use clean engine oil some time to clean my chain.
Use 140 grade gear oil
Agar chain tight karne ke baad kat kat ki sound aaye to chain jyada tight ho gayi hai kya???
Use chain spray
Yes
Vai front sprocket lock kaha mile ga
Service center par miljayeg.
What oil you are giving on sporket 😊
90 gear oil.
Lubricant kya use kiya? 😊
I normally use 90 gear oil. But in this video it was motul 20w 50 fully synthetic.
Phir bhi awaz Ara hai bhai pulsar 180 me
Bro can i use, used engine oil as a lube on chain ?
You can definitely... however it won't last that long as engine oil is thinner than the gear oil...
@@MOTOMENTOR thnq ♥️
It is a 50% solution broo.. actually you need to change the sprocket if it went torn... Well said I am good 😊
Bro lubricant use karne ke baad bhi awaaz aa rha hai awaaz dheere dheere band hoga ya kya karna hoga plz reply bro , Tvs apache RTR 160 2v 🙏
Chain kitne kms use hui hai koi rusting to nahi hai na ?
12000 km only @@MOTOMENTOR
Konsa oil use Kar raha ho bhai
Ye 90 grade oil hai you scooter ke gear mai data hai. Ye wala mai jo use kararaha hu ye motul ka oil hai.
आगे वाले स्प्रॉकेट में प्ले ज्यादा है तो कैसे ठीक करेंगे
Sproket change kare agar shaft ka problem hai yo shaft change karna padega jiske liye engine khol ke kam karna padta hai.
@@MOTOMENTOR मतलब खर्च लंबा बैठेगा
@@MOTOMENTOR लगभग कितना खर्चा आ जाएगा
Bhai mai ye sab kar chuka hu par fir bhi awaz nahi ja rahi hai, mechanics bol rahe hai ki shaft hi change karna padega fzv1 ka 😢
Shaft change boleto pura engine down and there is no option..... shaft change ke baad regular lube karna nahi long life ke liye.
@@MOTOMENTOR bhai aur kuch mechanic bol rahe hai ki shaft ko weld karlo, kya aisa karna safe hai ?
Na bhai aisa mat karna aap vo change hi Kara lo thoda costly hoga but aapki bike ke liye ye sahi honga.
Sprocket lock change karke deho, isse bhi fark padta hai
Kar Diya Bhai nhi thik ho Raha hai
makeing noise in new bike 3k kms only done, can this fix?
Yes ... also make sure the chain allingment is correct.
BRO LUBRICANT KON SA USE KARE ?
Motol ka
Yaha par lub oil leakage h kya kare
Oil seal change kariye.
Bhai clutch chodteh hi chain se awaaz aati hai?
Ye same problem mujhe b face horahatha and i fixed it..... Isi par video editing mai has inshallaha by next week I'll upload.
I have used almost 50k km in original showroom fitted chain sprocket in my ns200😅
Thats great 👍
Bhai new chain dala lock bhi new he, full lube he to bhi nahi ja Rahi ye noise
Which bike?
@@MOTOMENTOR MT 15
@@BhatakantiEkPravas check chain adjustment zyada tight mt rkhwao clean the chain with diesel or cleaner then use chain spray. Also clean the front sprocket and after that open front sprocket and apply good quality grease on front sprocket spline. Do try this
Bro there is a bend in chain , some areas in loose and some place is tied. How to fix this issue, it's roll on brazz chain, new one I barely used 3k km . Pleae let me know
To be very frank I had the same issue with the stock chain which I used for 18k kms and post using the chain lube and not cleaning it timely got the same issue which you mentioned... I tried to soke it in kerosene and diseal bit no joy I had the get my chai replaced ... what kind of lube do you use for lubrication and how often you lubricate?
@@MOTOMENTOR motul.or roll on, after loobing we have to tiet the chain it seems, I think I didn't done that last time.
@@gopikrishnankp have you seen my motule vs gear oil video ... I made that video after facing the same issue.
Use grease in front sprocket
Yup ... using high temperature water proof grease for extra protection
English
What did you put?
Gear oil 90.
Bhai konsa oil hai ye ??
Ye gear oil hai 90 number ... scooter gear mai jo use hota hai.
Fzs leke thoda pachta rha hu .. shal men 40k chalgayi hai .. 😅
Omg 😲 😱 😲
@@MOTOMENTOR aj kal gadi sab acche nhi reh rahe hain bro quality wise. Yamaha cost cutting karke bht degraded krchuka hai. Fzs product pura bigadchuke hain. Clutch repeat rubber ka issue toh 3000kms chalne k baad hi aagaya tha mere gadi men .
bro isse pehle honda hornet160r tha . Bs4. Maine usse 3 shaal men 1.47lakhs kms chala lia tha .. kbhi b usme clutch cover bhi kholna nai pada tha . Aur koi b part nhi change hua tha. 1.4lakhs kilomtrs chalne k bad bhi koi issue nahi aya tha hornet men.
Usse sel karke fzs lia tha.. yeh sochkr ki japanes gadi hai .bht last karega hornet jaise. But i was wrong .
Bas ek chis acha hai. FZS ka fuel injection system. Koi isue nhi create karta kabhi .so durable.
Apka kya point of views hai bhai??abt these brands
I agree with you infact in one of my video I have also mention about the new r15v3 clutch basket which k installed on my fsz the rubber of that clutch basket for faulty within 3k to 4k kms and I was shocked to see that... cost cutting ke chakkar mai ye log ne quality compromise ki hai .. mai b isi liys meri purani FZ abhi tak use kar raha hu coz is mai kaafi sare parts Japanese hai isiliye 13 years baad b ye tiki hai but hai abhi jo spare parts aarahe hai its not upto that mark. Sorry to say but ye logo jub se parts api country mai bana rahai hai quality kharab kardihai lekin kuch parts inke Indonesia aur Japan ke abhi tak aajatehai (galti se ) unki quality kafi aachi hoti hai.
@@MOTOMENTOR yes bhai!
Sahi kaha apne . Apka jo old model hai fzs..ussi model se inspired hoke maine new version lia tha Fzs ka.
Mera kabhi kabhi 950+kms ka b ride rehta hai .aur mostly 400km+ chalta hai ..(bht regret horhahai ab lene k bad FZS ) . Long route men jaane waale gadi men clutch ya phir engin related isue itne jaldi ane se bht bura feel hota hai bhai . Main rough b nhi chalata kBhi. Itne sab ke baad bhi agar issue aarha hai gadi men tab gadi ka manufacturing hi bekar hai .hadd se jyada .
Bht regret karta hu hornet se new fzs men switch karke. Beech men itna irritated tha ki 600kms rides kuch baar maine apne 13years old activa se kia tha 3-4baar... fzs ko decorative piece jaise rakhdia tha garh pe.🥺
Ap lucky hain bhai apne sahi time pe lelia tha..old model ..
Mere waale men mileage k alawa aur kuch better nhi hai. Sab chiz downgraded.
Aur
. Maine dekha hai apka r15 v3 wala clutch basket ka video fzs men.. aur uske bad jo apne sahi karwaya sound, clutch basket ke side wale pinnion change karwake .woh bhi maine dekha ..
Bht help Mila mujhe apke video se bhai .
Aur 3 oil change (2mahine k bad) men b wahi pinnion or clutch basket part change karwadunga. Ekdm se chalane nai hota gadi ab aur..jhatke pe jhatke deta hai bhid road men . I gues aj kal sabhi gadi bekar reh rhee hain . Quality issue ! Bikes se interest hi khatam hogaya hai ! Ab. 😔
@@MOTOMENTOR aur ek bada issue arise horaha hai new model fzs men ..(mere cousin ke gadi men hai)... Driving shaft jaldi khrab horha hai .. bas ussi ek part ko change karne ke lie full engine kholna padega abhi ..
35 k jhoot kam bol bhai😂😂😂😂
Saste nashe mai nahi karta agar jhoot bolkar views lane hote to 4 saal se mai million subscribers hote. I make videos on my personal bike and based on my personal experience ... dad was 2 wheeler expert and worked in baja sice 1976 he knows a lot and shares most of the trick with me.... whats your views on this ... I can 100% guarantee a sproket set can last minimum of 50k if regularly lubed and maintain. I have friends who have clocked 60k without changing the sproket set .... a lot depends upon the quality of the product as well and how someone maintains it ... no offense but yes thats the truth and you will only appreciate once you experience it.