DD13 DD15 DD16 Coolant loss/ DD15 Coolant Leak/ Low coolant level/ DD13 Low Coolant/ DD13 EGR Cooler
Vložit
- čas přidán 7. 09. 2024
- New Shop Info: goo.gl/maps/Hz...
TAT Express Inc.
972-225-3017
4140 Langdon Rd.
Dallas TX 75241
In this video, I go over a coolant loss issue for a DD13, Low coolant level, dd13 losing coolant, DD13 EGR Cooler this component can fail on a DD15 or DD16.
Low Coolant level can lead to severe engine damage. DD15 coolant leak or internal leaks can cause the oil to lose its viscosity leading to engine failure.
Regular maintenance can help in finding signs of failures at an earlier stage. Waiting too long to check on a coolant loss issue can lead to higher repair costs. DD Platforms are lightweight engines and if run hot or with contaminated oil damage can occur.
Check out my other videos Most common issues on ISX15
• Most Common Issues Cum...
18 Wheeler DOT Inspection
• 18 Wheeler DOT Inspect...
Most Common Issues with the DD15
• Most Common Issues Wit...
If this video has helped you in any way show your appreciation by buying me a coffee ☕️
Cash App:$tatexpress
If you have any questions feel free to reach out to us at
info@tatexpressinc.com
New Shop Info: goo.gl/maps/Hz...
TAT Express Inc.
972-225-3017
4140 Langdon Rd.
Dallas TX 75241
Join our Facebook group
/ 25176. .
Check us out on Facebook
/ tatexpressinc
~-~~-~~~-~~-~
Please watch: "How to Replace A Wheel Seal on Semi/ Wheel Seal Leak/ Wheel Seal Installation/100kMiles Inspections"
www.youtube.co....
~-~~-~~~-~~-~
~-~~-~~~-~~-~
Please watch: "TAT Express Live With Francisco Amaya"
www.youtube.co....
~-~~-~~~-~~-~
Very important information, this is a great diagnostic process. Keep it up!!
Thanks for the support Francisco, 🔧👊🏼
@@TATEXPRESSINC EGR didn’t take care of issue, was wet inside cross over pipe so changed it, coolant overflowing into over flow side and bubbles in reservoir and overflow hose going into a bottle - next idea the air compressor or a head gasket issue - can do a emission gases test but I can see the bubbles / pressure?? Just hoping not the head , never overheated dd15 650k also changed thermostat and both radiator caps what’s easiest way to check head issue?
Also no water in oil, in the past had injector cuff issue which may have caused the discolrization on the new reservoir - will do gases test in a few days when i get truck back from springs bushing job fix
I love both tat and Francisco Amaya videos so informative
We appreciate the support. 🔧👊🏼
Lot of people has egr.cooler failure.. I don't know exactly why because I have 10 of those truck and never had an issue with a egr cooler, knock on wood. I also do coolant changes and flush. I used deionized water and good ELC. I know this practice helps with oil cooler module corrosion. My coolant filters are always clean with no sign of trouble.
Thanks for taking the time to do this. Knowledge is awesome, lesson your chance of being ripped off!!!
Thanks for watching. Be sure to subscribe
I learned one more thing about Detroit engines today, thanks a lot mate
I’m glad I was able to help. 🔧👊🏼
I like to learn more every day and i thak you guys to show these kind of videos
Raul, thank for watching.
Thank you for the recommendations bro 😎 is so helpful for me as a owner operator
My truck is 2012 freightliner Cascadia shifts early on 8th, 9th and 10th gear and the RPM drops to 1000 even I changed the transmission.
Thank you
Have a 2009 Freightliner B2. Coolant loss is close to what this person has in the video according to the driver. I can't find any external leaks. It's a 6.7 Cummins. Oil doesn't look like it's mixed with the coolant. Right now I can't get the engine to crank. They didnt complain of starting issues before so I thought it was unrelated. I changed starter and batteries. Barely turns engine like when valves are out of adjustment on a riding mower, which makes me wonder if it's, sort of hydro locked. I now work on a fleet of school buses but Im a foreign car specialist and these were thrown on me because not many can troubleshoot in my shop. How can I see if there's coolant in the cylinders? Pull glow plugs would be the first thing I'd guess, right? I was going to try and turn the motor over by hand first but the crank is held on by like 6 or 8 small bolts and not a center bolt like gasser balancers. Thanks.
Thank for help us.. I have same problem ..DD15. 👍👍👍
2013 Freightliner Cascadia DD15
Scenario: Bobtailing at a light... in 3rd gear.. light turns green...let’s off clutch, hits accelerator... truck hesitates for a second before power kicks in... seems to happen when rpms low, low gears when taking off
Diesel engines will have some lag but if you suspect power loss than I would recommend having truck checked out.
New dd15 loosing up to 4 litres a week. Oil looks good and not rising.
Thankyou, your video is very helpful
Adam you are awesome 👌 👏 guy I live in Seattle area but wishing to see you 😀 😊 one I have low power to my truck 2016 dd13 freightliner cascadia I your advice 😀
Good presentation 👍
We appreciate that sir.
What would cause the coolant reservoir to be 1-2” below the minimum on a DD13 but then when you run the truck and just idle it for 20 minutes it goes back up to normal level?
Very important tip, my oil level is raising. But it's not changing the color of the oil ? I just started driving this truck last week and it has already gone through 7 gallons with no visible signs of leaking, ACCEPT FOR RAISING OIL LEVEL !!! but the oil is NOT milky colored still black and thin !!, Thanks for this. Tip. William.
More of it could be going in the combustion chamber than of oil galleys of the block.
So basically when the Piston goes down it's sucking in coolant.
Or it might not be in the oil galleys at all and coolant is sitting on top of the piston and working its way past the rings when cold.
There's 10 to 12 gallons of oil in your engine so only if a little coolant is getting past it might not necessarily make it milky until a few more gallons of coolant gets in your oil.
Definitely get it fixed soon as possible and go online and find a reputable oil analysis website. For sample from your oil and send it to them.
I personally use testoil.com
How is the coolant lost? Where does it go? So the fix is changing the EGR cooler? Thanks. I enjoy your vidz!!!
Coolant goes through the EGR cooler to cool off exhaust gases before it is recirculated back into intake. When the EGR cooler fails it will leak coolant as shown in video.
@@TATEXPRESSINC if coolant leaks can a delete solves the problem because I have same issue coolant loss gallon a day and it’s not external
@@adamotak5145 how did you fix this issue?
@@expert1219 they finally found out it was external leak under reservoir and driver side fortunately not internal
Great video thanks for the tips
Great video as usual! Keep it up!
Thanks Niko
Excellent info
So we've got a DD15 in our shop right now that is losing all its water into the oil pan. We just replaced the air pump/compressor on it last Monday and this problem happened that following Friday. Would a defective air pump be the cause of this, or something else? Because it was fine the whole time we had it. Any advice/info is appreciated.
Hey man i got 2015 box truck international 4300 so truck don't crank dont start i tried to start it all i get its click click on fuse box by Basinger said
My red engine light comes on for about 15 seconds sometimes and I get the very low coolant warning but when I check it the coolant is fine. I want to add some but I'm afraid to over fill it. What could be the problem?
Would you get a coolant smell in the cab.
Dd13 losing coolant but no external leaks. Cooler tested and good.. no coolant in oil. What else could it be
2022 freightliner cascadia just happened in my truck i84 all of the sudden 40sec engine shutdown. Added 8 bottles of water and dont know what to do
Adam, I am losing coolant but I put a pop bottle under the overflow hose on the gaseous bottle and it's filling it up. What's causing this?
Welp no visible leak on a 2020 freight-liner, I tried some heavy duty coolant sealers but still needing to top it off a little at the end of the week. It has 331k miles on it and the company sells em around 400k. It runs fantastic besides for the coolant loss. Should i even bother trying to get the company to fix it, waste a week without pay. Or should i just run it?
Hello i did pressure test there is was no leak found. the engine is not get overheating just lose antifreeze on reservoir tank 2 quarter around 1200 miles the EGR is clean no antifreeze inside. Any recommendation. thanks
I’m having ignition issues sometimes the truck starts with key but most days the truck has to be started with switch that’s attached to starter can you all do a vid on how to diag a bad starter
Good idea. Thanks for watching. What type truck do you have?
Cascadia dd15
I got a cascadia dd13 2014 there is water in fuel tanks chowing on my dashboard and the truck breakdown and won’t start I towed to the Michanic he said this is a electrical issue so he replaced the electric engine harness and 2 sensor and the ecm I took it for A drive test I broke down again have you any idea what is the issue. Thank you!!!
I have a severe coolant loss I run Chicago to Michigan every day I was 250 miles away from home just pick the truck up from getting brand new radiator 50 miles down the road I am overheating it took me 12 gallons of coolant to get back to Michigan I don’t know what to do now any suggestions
I will be working on a 2021 Peterbilt 520 McNeilus does this have the same set up for troubleshooting coolant loss?
what can you tell mi for Volvo 2007 tank owerflowing reservoir. vnl d12.
Can you smell it in the cab?
I got a 2015 dd 13, getting coolant into exhaust. Replaced egr cooler, went from losing 2 gallons a day to a gallon a week. I removed exhaust pipe from turbo it's dry but there's coolant in exhaust is it possible for doser valve to Crack and leak coolant into exhaust?
Hi i have similar issue on coolent leak the hoses on the passenger side was tight bad thats where the leak is coming from.To fix do i need to replace the radiator
Mohamud, give us a call during business hrs. We would be more than happy to help. 972-225-3017
Can this happen on the cummins X15?
Are you saying the hot side of the EGR coolant should have no coolant and that if you are losing coolant it might be going to the hot side of the EGR (where it is not supposed to be)?
This is exactly what happen to me
My 16 cascadia is leaking puddles on the ground. Its visually seeing it from the right side of the motor on top. Leaks too low then the stop light and check engine light starts flashing on dash, then the engine cuts off to protect it. I fill up the coolant reservoir then crank her up again. I'm having to add coolant once or twice a day. This just started 3 days ago. Guess it's not the EGR but any idea what's wrong? Thanks!
Hey anyone know why the coolant goes down on the surge tank when you accelerate DD13? Than when you let go of the throttle the coolant rises back in the surge tank? It literally goes below min and than back to max when you let go of the petal... once a week we have to add half of gallon...No egr leak... Please help anything ideas helps
I Have Same issue with my 2019 Cascadia dd15. I take to the dealership they take 10 days and they said coolant hoses are not good. So they replace it but after a week more worst truck takes one-gallon coolant in a week. It's just disappeared no leaks also check the oil cap but I don’t see any coolant mix with oil. Could you please suggest me what should i do . I can bring the truck to you guys if you fix it in 2 days, please let me know
Thanks
Need help you are smart Volvo 2007 cammin engine over flow just got it need help please
em thick anh lắm, lần sau anh quay clip dài dài nhé anh
Thanks for joining us
I have small leak coming out the cap
So we have to change EGR??
ANY VIDEO HOW TO DO IT??
Yes EGR cooler needs to be replaced. Thanks for watching be sure to sub
I have a dd15 that is pushing coolant out the coolant tank already replace de coolant tank and thermostat and still having the same issue
hey did you resolve it if so what was the issue bro
I am assuming you use a Stant pressure tester. Do you have the adapter part number? The Stant web site lists adapter part number 12032 but it is too big to fit in the hole.
Rick thanks for watching. I will up load part number ASAP.
Thank you. I am going through about a quart of coolant a month. I am suspecting the heater core because occasionally I get a slight coolant smell inside the cab. I try to do all my work myself because I can't afford the down time of taking it to the shop. Between you and Francisco Amaya I have been able to do the majority of my repairs myself.
By any chance, were you able to find that part number yet?
i have same exact issue,loosing two gallons of coolant a day, where u guys are located.thank u
My cap started leaking & now I have coolant on the bottom of the Reservoir what can it be?
Good morning
I have a dd15 as well. My dd15 is deleted. Will the egr still be an issue?
I have dd15 with 780000 mile and my coolant start leaking from Exhaust so any idea what it could be..thank you
Loosing coolant no leaks seen
What did the cold side look like? Was it just sooty?
How do you find the DD16 engine? I mean pulling power & mpg etc....
Where are you guy located at?
How much does an egg cooler cost plus labor?
Hello guys I’m having problems with my FreightLiner Columbia I’m loosing cooling also there’s oil mixing in the cooling tank any ideas what can it be and is not the oil cooling i already fixed that so any ideas might be
Detroit 60 2008 forgot to put those info
I've put 2gallons of coolant in truck it want fill up
Is it normal to add water every 2 months?
Where you guys are located I’m looking for for a good mechanic
Dallas Tx.
Call us during the week at 972-225-3017
what if the EGR is eliminated?
I have cat 3406e no egr, I’m loosing a lot of coolant but no leak. Can you please help me tell me where should I find my problem
Head gasket.
Got a D60 12.7. It’s running hot. If I pull a load with a little weight to it up the bridge, the temp gage reads 210/220. If it rains, the temp goes down and looks good.
Does it sound like low coolant, or clogged radiator?
How many miles? Has the radiator been serviced before? I would service the coolant system and inspect for proper cooling
TAT Express Inc. little over a million. Hasn’t been serviced since I’ve had it. 2 years.
Can the EGR cooler still be the problem even if the EGR system has been deleted?
I need to know too did you got an answer
Detroit engines shit mate