Preparation of Humic Acid from Lignite and Potassium Hydroxide
Vložit
- čas přidán 25. 08. 2024
- The preparation of humic acid from potassium hydroxide (KOH) and lignite involves a series of steps. Here's a practical method for preparing humic acid:
Material Preparation:
Obtain high-quality lignite (a type of coal rich in humic substances) from a reliable source.
Purchase potassium hydroxide (KOH) in pellet or flake form from a chemical supplier.
Use distilled water for preparing solutions to avoid contamination.
Lignite Treatment:
Grind the lignite into a fine powder using a grinder or mortar and pestle.
Dry the lignite powder in an oven at a low temperature (below 100°C) to remove moisture.
Alkaline Extraction:
Prepare a solution of potassium hydroxide (KOH) by dissolving it in distilled water. The concentration of KOH solution can vary depending on the desired pH and extraction efficiency.
Mix the dried lignite powder with the KOH solution in a suitable container. The ratio of lignite to KOH solution can range from 1:1 to 1:5, depending on the desired concentration of humic acid.
Stir the mixture thoroughly to ensure even distribution of KOH and lignite.
Extraction Process:
Heat the mixture gently on a hot plate or in a water bath while stirring continuously. Maintain the temperature below boiling point to prevent excessive foaming.
Continue heating and stirring for several hours (typically 4-6 hours) to facilitate the extraction of humic substances from lignite.
Monitor the pH of the solution periodically and adjust it by adding more KOH solution if necessary to maintain alkalinity.
Filtration and Separation:
After the extraction process, allow the mixture to cool to room temperature.
Filter the solution using a filter paper or a fine mesh sieve to separate the solid residue (insoluble materials) from the liquid extract (containing humic acids).
Collect the filtrate in a clean container and discard the solid residue.
Concentration and Purification:
Concentrate the filtrate by evaporating the water using a rotary evaporator or by gentle heating in a glass container.
Once the solution reaches the desired concentration, allow it to cool and crystallize.
Purify the crude humic acid by recrystallization or chromatography if necessary to remove impurities and obtain a pure product.
Drying and Storage:
Dry the purified humic acid crystals in a desiccator or oven at a low temperature to remove residual moisture.
Store the dried humic acid in a tightly sealed container in a cool, dry place away from direct sunlight to prevent degradation.
By following these steps, you can prepare humic acid from potassium hydroxide and lignite effectively for various agricultural or industrial applications. Adjustments to the procedure may be necessary based on specific requirements and available equipment. Additionally, ensure safety measures are followed when handling chemicals and conducting experiments.
homemade humic acid for plants
how to make granular humic Fertilizer
how to use humic acid for plants
#homemadehumicacidforplants
#howtomakegranularhumicfertilizer
#howtousehumicacidforplants
#humicacid #lignite #potassiumhydroxide #organicchemistry #agriculture
#soilhealth #fertilizer #organicfarming #agronomy #chemicalprocess
#research #experiment #sustainableagriculture #soilamendment #nutrientmanagement #chemicalengineering #agriculturalchemistry
#biochemistry #science #cyberagriextension #cyber #agri #extension
Jazak Allah Hu khaira
Thanks Dear
Great effort and product.
Please also try hydrogen peroxide with lignite, you'll get great results.
Okay. Thanks Potassium hydroxide contains 90% Potash too
Sir, are these products available in smundri?@@CyberAgriExtension
@@zulfiqarkhan9630 No sir you can buy from the sitara market fsd
great day! would you give us measurements? what percent hydroxide? how much hydrogen peroxide? how much lignite? also the process - how you do it? mygreathanks and blessings
great service...what are the measurements? how many liters of water? how many grams/kilos of potassium hydroxide and lignite? mygreathanks and blessings
5.25 Kg KOH
17 Kg Lignite 60%
100 Liter water
@@CyberAgriExtension wonderful...thank you so very much...blessings
@@CyberAgriExtension lignite is 60% humic acid you mean? mygreathanks and blessings
@@CyberAgriExtension hello, first off, mygreathanks and blessings for this. application rates per hectare?
Sir how much it would affect soil with tons and tons of mass and just 3 liters only?
humic acid is believed to improve soil structure and fertility in moderate quantities, excessive or indiscriminate application can have detrimental effects on soil health.
Leginte aur cast soda keha se mal ga.sir
Chemical market se mily ga, Faisalabad main Sitara Market Satiana Road pa ha
السلام وعلیکم سرجی یہ چیزیں کہاں سے ملیں گی
Chemical Store se, Faisalabad main Sitara Market Satiana Road Saleemi Chowk
Lahore Akbri Mandi se
Thanks. It's pH?
Dr. Sb I didn't check it's pH.
Ye kitny din bad use krna Zameen me??
03 hour k bad istmal krskty han
Thanks bhai Jan
Doctor sb ye lignit or KHO khuly kahan sy milen gy
Chemical Market se milan gay
@@CyberAgriExtension faisalabad mn kahan ha market sir
@@muhammadsohail-de3cnfrom sitara market fsd
Potassium hydroxide lignite