But you didnt mention the imrcv (intake manifold runner control valve) aka swirlflaps that retard air flow at low rpm for fuel efficiency. Eventually wear down. If one flaps falls before you fix it' it falls into the cylinder which causes catastrophic failure. Great video other then that. I have 07 zx3 five speed. If you could do a video addressing a perma fix. zx owners would owe you 1. Ive heard you can take the flaps out put back bearings and main rod as to not get a check engine but also eliminate the risk of motor dieing.
On my 2003 and 2007 Focus, I've gone through 5 engine mounts so I can vouch for #2. The 2003 also had the ignition core go out. 2007 had a bad alternator too, so I'd say this video is spot on!
I just bought a 2007 Focus with 175k miles and it shakes like nobody's business. This video was so helpful, just ordered the motor mount and transmission mount kit from 1A, looks easy enough to install!
I have a 23 year old 1.6 Ford Focus manual. 181000 on the clock. Still has the original alternator, water pump and radiator. Never had any problems with keys in locks, electric windows and no engine warning light on. It's a great car.
Just bought a 2004 Ford Focus wagon, 181 on the clock and $1000 from someone who wanted an upgrade. First car I’ve had with zero rust. Had this as my first car 6 years ago and loved it. Changed the motor mounts so in the future it’s a easy change for the new car. Really excited for this baby. Basically a mini mini van with 28 mpg.
As someone who has owned a 2002 Ford Focus for 10 years, these issues are all too accurate. I’ve replaced everything mentioned at least once. Great video
Our 2007 focus 3dr hatchback has been a great running car. We purchased it used in 2009 with just under 40k miles it currently has 133k. Normal Maintenance has been front and rear brakes, rotors, drums, tires, ac top off, oil changes, and coolant flush. I have replaced the driver door locking actuator, both lower control arms due to deteriorating bushings, a muffler. I save a lot of money by doing all of the repairs myself.
My original engine is now hitting 300,000 miles. I have transmission problems but it is a junkyard replacement Transmission with 200,000 miles on it. Some were very HARD MILES meaning I lived 2000 feet up a mountain and had to drive it daily for around 3 years of the life of the car.
It's a odd beast, most of the time the first gen of a car is the absolute worst for reliability but the first gen Focus is the best focus for reliability, they started going downhill after until we got the current one with that shit transmission
The zetec engine they put in those is damn near bulletproof, I've owned three of them and I beat the living snot out of them and they willingly take it. Only issue I've come across was a tiny leak in the valve cover gasket on one of the three, the other two have been just fine
Have not had any of those issues with my 2007 Focus. Most bothersome issue is wheel bearings: Have done 3 wheels so far. Next is oil in spark plug wells, so replace cam cover gasket. That's about it. Still going strong right now with 123K miles on it.
Great video! NYer here. I have a 2001 hatchback Zx3 with 262,500 miles. MANUAL transmission. It's still going strong. It has the window regulator issue on the passenger side, but it hasnt completely stopped working yet. Today I couldn't get the key to turn. It took me about 15mins and 3 dozen attempts to get it cranked over. It also has that bogging out issue with fuel pump. Other than that very reliable car and fun to drive.
Hes CORRECT about the motor mount. I bought my 01 ford focus 5 months ago and i had to replace the motor mounts twice! And the ignition part where my key always gets stuck and wont turn! Thanks 1A Auto, i love watching your videos! Im a woman and all these videos are very helpful for me, when it comes to fixing my car!
09 Focus over here. I've put the original 54k miles on it. I hope it lasts forever! Everything is original on the car except the transmission fluid, engine oil, tires, motor mounts and AC evap. It's a good reliable car so far.
I just recently got a 2002 ZX5 from a police auction with 206k miles for $910 and MANUAL TRANSMISSION which is the MAIN REASON I got it (they are getting HARDER to find). The key thing is something that I did have a problem with from the get go, I lubed EVERYTHING possible that may not been done in GOD KNOWS HOW LONG. The oil was quite clean and SURPRISINGLY everything important appears to work ok even the cruse control.😯😁 It RUNS PRETTY GOOD, have to restrain myself from ZOOM ZOOMING to much because it RUNS SO WELL especially because of the manual transmission. It actually handles pretty good as well, need to replace the tires in the reasonable future because when it rains and if I'm speeding a little it does slide a little but not too much but enough to keep me from pushing it too hard in the RAIN. It holds the road GREAT when the road is DRY. IT HAS PUT THE FUN BACK INTO JUST NORMAL EVERYDAY DRIVING.😄👍😎
Good Video. Thanks! As a professional locksmith, the main reason the ignition swithc goes bad is from people who hang a ton of crap on the end of it. It pulls down the rear, tips up the tip and wears things out. Also all locks in American cars are made with brass pins or side lock wafers. If you are not using a brass key, you are wearing out the key AND the lock. Also those window motors ? OMFG what a Byzantine bow string winding cable confusion those are!!!
I absolutely love you all for helping me to be able to figure problems out. I just bought a 2007 Ford Focus 163,000m for a $1,000. First things I notice is there's no defrost and the windshield wipers don't work. I hope I paid a good price. Oh and engine light is on so I'm trying to get that to turn off before I even go to inspection.
Very accurate my dad used to have an 03 Focus and we replaced every single one of these parts mentioned. Some of them even multiple times with that said though it was a great little car had 270K when he got rid of it, and still ran like a champ.
Key stuck in the ignition fix. Below shifting knob is a plastic tube running down through the console. Gently pull up on that tube and release. Problem solved. Worked for me and hasn't happened again in over a year. Love your tutorials. Thank You.
You're adorable! Thank you for the helpful video! Im on my second ford focus wagon; I love them! And yesterday the ignition went on my new focus, but I knew how to fix it! I saved myself a lot of money by drilling out the ignition tumblers, then using hot glue to secure my key inside the drilled out casing. So, basically, I just claimed this car as MINE, for the rest of its life!
I have the problem with the key getting stuck in the ignition. My friend came over and showed me a trick to get it out on my 2007 Ford Focus. She moved my shifter You can shift it from park to anyone; drive, Nutural reverse, etc. then pull the small plastic ring on the shaft (just below your hand). Pull the ring up sometimes I have to turn it now that I have been doing it for so long. Put it back into park and try to see if it releases your key. I sometimes have to try a few times. It happens every once in a great while. So I haven’t found the need to get it fixed. Hope I explained it well. I am no mechanic and not mechanically inclined by all means if u can’t tell lol I just wanted to put this out there. If it wasn’t for my friend showing me I would have been screwed with having to leave my key in the ignition and having to pay $$$ when I didn’t have to for anyone who can’t afford and save the money for other repairs (maintenance) on my vehicle. I don’t recommend anyone driving my vehicle without me in it to explain the different things u may need to know or u may not depending on my vehicle that day 🤷🏽♀️ it can be a bi bipolar like it’s owner 🤦🏽♀️
I love this site. Number one...he keeps it brief. Most go on and on and there are more ah's and ugh's than spoken words. Video quality is excellent, you can watch the repair and see what is going on, so many don't cover the entire process because the camera light source is not enough. I trust what I can see as it is being explained or performed at the same time. I go to this site first, always.
Hi, I've had my ford focus zetec mk1 hatchback for 11years now in England, and I've had no problems at all with the issues you've mentioned, I must have got a really good one when it was built in 2004, but thankyou for the video, at least I'll keep and eye out for any of these problems, should they arise, I watch all your other videos, they are very informative and you make them easy to follow, so keep up the good work,
I got my with 30k now has 142k. Fuel pump changed on my at 130k Engine mount at 120k Window regulators 2 times changed Key never had an issue Alternator never changed
Im at 170k and car is down got a new alternator just gotta put it in already put in a new battery and havent need to do any of the rest although i should replace suspension but is the car really worth it at that point? Knock on wood I dont have any issues with the fuel pump
Just watch out for when you need an alternator. If you still haven't replaced your alternator, I'd keep some flares in your trunk. When the alternator goes out, your battery will die leaving you with no lights. Nothing to freak out about, just be warned.
The problem i had when i got it was coolant leaking where the thermostat is at. As the part is made of plastic with heat being in the mix. Exterior part starting to come off like rear view mirror. Other than that just keep up with the fluids and filters.
@@joelvarelajr6495 Lol coolant recently started to leak for me, also the plastic coming off I had an alternator problem, broken bonnet lock, most annoying thing is instrument panel going bad with all engine, esp, acceleration reduced errors, rust does to my countries weather and use of salt (had rusted hole below driver seat) also changed the starter. I am thinking to get rid of my Ford Focus 2007 besides at my country local craigs list alternative portal is full of FOCUSes for spare parts........
I've experienced the windows and fuel pump issues. Other common problems on these are the speedometer going mad and AC blower motor resistor fail. Brilliant cars otherwise.
My speedometer goes crazy too! I thought its from overcharging battery, which could be due to voltage regulator inside alt. Did you fix yours? Or do you know the certain 'cause of it?
@@jeaniejpeck-barge5778 Bit of a late reply. Its the speedo sensor that's faulty. I've had 3 Focus' and 2 have had the exact same issue. Cheap part and easy to do after watching a few videos...
i have a 01 focus zx3 i have had since i graduated in 01 i can attest to all these things , and right now im currently in the process of replacing the fuel pump and filter
Don't forget the EPFS(Egr Pressure Feedback Sensor) and the Crankcase Emission Breather hose...the first one connect to two metal pipes via two short rubber hoses...the parts from the sensor that connect to the hoses are plastic and tend to crack overtime due to heat...#2 is a little hose that connect to the crankcase vent system and is located behind the intake manifold...it become to soft overtime due to the heat and tend to strangle...both things when bad can cause the engine to stall very badly and sometimes lose power or turn off.
I bought a 2006 Focus new and have never had any of these issues. The biggest issue is that the "sonic blue" paint falls off. Second biggest was the engine control module went out after about 5 years but it was still under warranty (although the car was only a 3 yr/30k warranty). Had to replace alternator, thermostat, battery of course, fuel pressure sensor, plugs of course.... it's been a perfectly reliable car, despite what numerous Toyota fans told me. It's been my daily driver for 15 years plus several cross country trips and has never left me stranded.
great video very accurate. i've got a 2003 ZX5 that i bought new. 165.000 miles on it now. I've had to replace the driver window regulator , alternator , engine mounts and i've had to pull the ignition switch and just remove the tumblers. only other thing i would add would be i've had to replace the thermostat housing twice. they are plastic and crack. All in all it's been a great car.
My 07 worst problem has been the idler pulley bolt breaking. After the 3rd time I drilled and tapped the hole to 1/2 and used a grade 8 bolt and it has not broken since.
That was EXACTLY what I needed to see AND when I needed to see it. I've been at war with mine for bout 2 years and think I've put MOST of these common issues behind me. Somehow even with all of the NEARLY back to back or reoccurring issues I'm addicted to this thing. Never thought a roller skate would be this much fun to drive. Would like to KNOW what may be ahead for me here so JOE Hyndai Tech if ur still around I think thst I would like to communicate with you if you don't mind.
I have had 4 Focuses (2001, 2003, 2007, 2005) since my first one back in 2006 and I've had incredible luck with each one of them but I definitely had the motor mount issue on all of them, as well throttle position sensor issues on the first three and an idle air control issue on the first two. I love these little cars and always end up regretting trading them in. Recently, I decided to get a back-up vehicle so I found myself a 5 speed 2005 full of all the "bells and whistles" with only 100k miles (my first hatchback/two door) on it in amazing shape for super cheap and don't plan to ever get rid of it. I actually got my second Focus up past 300k miles before selling it (four kids, needed a third-row SUV) and not once did that car let me down so I've got high hopes for my most recent purchase, being that it has such "low" miles on it. I'm not a Ford guy by far but I can honestly swear by these extremely dependable little cars.
I've got a 2001 zx3 since 2011 and mileage is 255600 and it gave me problem recently with the transmission ! I put Lucas in the transmission and it certainly has given my car another chance and a second wind as the acceleration grows and grows! Lucas is like a mechanic in a bottle! My mechanic told me he didn't want to work on it because he just knew my transmission was gone! Now he's surprised because I'm asking him questions about another problem because he thought the last problem the Transmission killed the car adventures! Not so! LOL
Have had most of these problems on my 2001 Focus wagon. Have not had any problem with ignition key, keep it lubed with spray dry lock lube. Fuel pump gave up about 4 or 5 years ago, was replaced by Ford for free, caught fuel pump recall in its last few months! Motor mounts need changing every year or so if you use the cheap ones, (Arrow), from parts stores, use oem parts on this. Window regulator cables broke on left rear door, other doors OK. Bigger problem is all four door handles broke, small pot metal part breaks on handle reinforcement, only metal part and it breaks! Alternator, on third one, used local rebuilt part and it dies after one year warranty, used pro rebuilt alternator the last time- no problems!
You are spot on. I have been playing with my keys getting them in and out of the ignition. I have a 2005 focus. Zx3. About 220,000 miles and still runs like a champ though. Great video.
That's one of the early Duratec ones. All the early Duratec motors had a whole set of extra issues. The Zetec motors were a rock-solid design, largely perfected on the original Escort platform.
My first car was a used 2005 Focus ZX3, had it since 2017. Literally the moment I bought it from the previous owner I switched on the head lights to drive away, an electrical fire broke out. Quickly put it out and the owner had the electrical issue fixed a week later. Only reason I didn't back out of the deal was because the car had 65,500 miles on it
Dealing with my ignition cylinder right now. Thanks to you I now know what it is. Who to get to fix it is the challenge now! Thanks for your help. Great video!
Excellent video. Thanks. Our 2000 Focus SE has some of these problems, including the stuck ignition key (7:13). A temporary fix is to gently tap (toward the steering wheel) the end of the key. We keep a hammer under the driver's seat.
Ive owned an 02 ZTW Focus Wagon for many years and for years have been wanting to upgrade and fix alot of issues..and finely found the time and money to do so! So Id say within the last 6 months, you name it and chances are I've replaced it. Long story short?.. I don't know what I would have done without the 1A Auto videos. Seriously, I have been very successful at fixing our Family Focus Wagon and I just want to say thank you..Especially to the gentlemen in this particular video. I'm horrible with names..(I call you the bonk bonk guy) lol. Hands down you do a wonderful job. Keep doing what your doing sir.. and Thank you!
+Heath and Val Hutchinson Thank you! We love empowering our customers and showing how to perform DIY auto repairs with our high-quality auto parts. 1AAuto.com
Just bought a 2007 5-speed with 190000 Miles. Body was solid. Power nothing which is great. Less to fix. He wanted 26 and I got him down to 23 hundred. Great running car and thanks for the info on what to look for going bad.
I love mine. Had it for a year. 175 k and runs nice. Gonna change some tie rods and links and look at the steering pump. Other than that minimal work and I love it
the #1 issue with the 00-04 focus was the SPI engine dropping valve seats. probably not a problem for any cars left on the road because all the SPI cars are scrapped by now. zetec and duratec engine options were bulletproof
Well I started buying alot of my parts from 1A auto because auto zone and such always send me the wrong part for my v8 impala. They always give me a v6 version and they don't fit at all. But you guys haven't let me down
This was extremely helpful, nobody could find the cause of my car shaking and stalling. My check engine light has been on for months, so many me panics and wasted time and money, thank you very much!
You forgot to mention the valve cover gasket! If you see oil on top of the spark plugs when changing them or smell oil burnt oil when driving it could be the valve cover gasket. Don’t worry it is a very easy and cheap fix! I own two focus’s, a 2011 sedan and 2007 hatch. Great cars!
It's not what I know, but who I know that gets me to where I need to be. It's who I know that translates into what I know. Thanks for taking the time to share with us your knowledge. Knowledge is good with an inheritance, and by it there is profit under the sun . Can you imagine if someone like Newton or Einstein had never shared there knowledge ? We'd be left guessing in the dark about the mysteries of the universe .
Dude, u nailed everything! Every single thing youve talked about, ive dealt with (or am in the process of dealing with)! Subscribed & thank you for ur knowledge
We have a 2007 Focus and it's a trooper. > 200K miles on it, and it still runs like a top. The only one of these issues we've seen is the alternator (but we've had to change it twice!). Now I want to check the engine mounts though, because it does seem to vibrate a lot when idle. (It's never been the smoothest running car, so I guess it never occurred to me there might be a problem.) We also cracked the steering rack on it, but that was... uh... operator error. 🙄😁 Thanks!
Great video clear and concise friendly and informative. I'm sick of being ripped off n lied to or of the assumption I know nothing about cars ? Thanku your my mechanic now cheers
+Jo Hackston Thank you! We love empowering our customers and showing how to perform DIY auto repairs with our high-quality auto parts. 1aau.to/m/Shop-1AAuto-c
I bought a 2002 Ford focus zx3 bare bones with a manual transmission. It was a relatively reliable car, but I've had the fuel pump issue which eventually went away and was never replaced and the ignition cylinder, which was replaced. I've also had the valve cover gasket leak which I replaced, the catalytic converter which was replaced, then the AC blower motor went out before I sold it. It had 174, 000 miles before I let her go.
excellent video thanks. On our 2003 manual Focus we have to replace one or both of the front anti roll bar drop links every year as we have awful country roads in the UK. Another common fault with these cars seems to be that the coil packs split causing misfire under load.
I've experienced every one of those problems! So ironic lol. Also my back hatch sometimes doesn't close quite right which leads to dead battery the next day.
That's funny.. I just got a free zx3 and its idling rough as hell to the point it dies and I need to replace the master cylider for the clutch. Been off the road 3 yrs I'm told
I got Focus 2001 Ztec actually runs 215,000 miles and counting, about common faults yes i be experienced alternator, window elevators (4 doors) and motor mounts, the rest no problem yet, excelent car if you take care and give good preventive maintenance.
My mother owned an 03 Focus from 2004-2016. Was a solid reliable car. I have so many fond memories in that thing. If it wasn’t for living in the damn Rust Belt we’d still be driving it
My alternator went out in my 04 svt. I drove it that way for 6 months by plugging in to a battery charger every night. I could drive it to work, out to lunch and home no issues. Maybe total of 10 miles a day 5 days a week.
I had a 1990 Geo Storm and it lost the alternator belt on a long trip and never gave a problem even night driving for 2 days until I replaced it. That is reliability for you.
I was afraid 2007 fell under the 1st Gen. Thanks for this video. Shed some light on the shaking and loss of power with the 1st 2 problems. People trying to get me to buy a new transmission lol. Gonna hope it's just this and save up to pay for repair
The motormount that is at the front of the engine under the coolant reservoir. is a liquid filled mount and they frequently go bad. and the ignition switch, if a person is having a problem with removing the key from the switch. they might check the shifter because they have a safety incorporated in them. that won't let you remove the key unless the shifter is all the way in the park position. of course that pertains to automatic transmission models only.
JUST BOUGHT ONE, HAD THE WINDOW ISSUE HAD FIXED, WENT AHEAD AND DID THE MOTOR MOUNT. OVERALL I THINK ITS A GREAT CAR I LOVE THE WAY IT DRIVES. JUST A LIL TRIMBLE ON TAKEOFF OR IDLEING BUT I THINK ITS WILL DRIVE OUT FROM SITTING AWHILE GOOD INTERIOR BUT DASH BOARD LIGHTS ARE DIM ANY SUGGESTIONS. GREAT FOR MY PROSTHETIC LEG GETTING IN AND OUT OF AND LOTS OF ROOM FOR WHEELCHAIR IN BACK HATCH OF WAGON. THANKS FOR SHARING YOUR VIDEOS I LOVE WATCHING AND LEARNING SKILLS
Before you replace the ignition cylinder, make sure the plastic sleeve around the gear shift hasn't dropped down into the console preventing it from going into park. I've had this happen a few times and the result is you can't take the key out. You can just push it back up into place.
I work on many of these ford focuses from 00-11 mostly work on the 2.0 duratecs. there are many common issues that are not listed in these videos. -Valve cover gasket, the seals around the spark plug holes give out and will leak into the spark plug hole, usually it doesn't cause an issue but if you go to do plugs and find oil then you know the vcg is due for a change. -front lower control arms, these have a tendency to rot out because if the design, and the rearward bushing is a common part to wear out. -water pump, very common for the bearingon the shaft on the waterpump to start letting coolant through usually doesnt leak enough to be noticeable unless you're specifiaccly looking for it. -Rocker panels, from 00-11 ford used some chip guard paint on these rockers, if you live in the rust belt then you probably see alot of focuses with rotted rockers, the chip guard coating they use traps moisture and they rust from the inisde out usually. -08-11 focuses tend to have the front calipers sieze alot more than the other years.
Like to thank you for joining my memory as I completely had a brain fart yesterday felt clueless, sounds daft when I passed my level 2 mechanic last year
I've owned 7, MK1 ford focus, their great cars overall, yes, the cheaper motor mounts are an issue, as the aftermarket ones only last a year or two if you're lucky, as motor craft (OEM Ford product) does not make them anymore, and those were the best at the time, as you'd not be replacing them as often. The ignition key tumbler issue is also exacerbated by heavy keys on your key rings, as it will warp the tumblers in the cylinder, causing the issues mentioned in the video. The alternator wiring harness usually after 5 years or so will eventually corrode due to age and the wires will sometimes fall out of the plug ends of it, and replacing it is the only solution, as the early warning sign of this is the battery light flashing every so often to tell you the battery isn't being recharged, if you ignore it will eventually stay on once the battery warning light stays on full time, and you will kill the battery if you don't replace that stupid harness. As for the fuel pump, it was an issue in the first model years (2000, 2001, 2002) where there was a recall by Ford about this, the other issue related to the fuel sputtering issue is a clogged fuel filter, as that is also something that needs to be changed every 50,000 kms / 35,000 miles as it will clog up and cause the same issues as the bad fuel pump, there was a TSB about this issue in 2002 / 2003 for the earlier model years and the fuel pump recall was for all focus's from 2000 till 2002.
2000 ZX3. I've replaced the ignition cylinder, alternator, battery, ac clutch(without removing the compressor or losing the 134a), motor mounts, hatchback latch assembly, front struts and springs, exhaust hanger, timing belt, serpentine belt, and maybe a few other things I can't recall the name of right now...but the intermittent check battery light is the one thing I can't seem to beat.
Just sell the vehicle, I replaced all those things to & the engine still blew out. I should have sold it. & bought a Toyota. Spent 2,000$ on the vehicle & 6,000$ trying to fix. Worst vehicle ever.
You are right about the engine mounts. Mine is a '06 and a resppecfully 305000 kms...consume no oil doesnt leak and everything works. Even tha a/c...nice vidéo thanks!
I just purchased a 2009 Ford Focus. It only has 47k miles. But today I noticed the back window won’t go down, the engine shakes like it needs a motor mount, and I replaced the battery after the first week I owned it. Looks like these are common problems with the Focus.
I actually replace mine in my 2007 Ford Focus Zx3. It literally is sofa foam in a sealed box wih a plastic mesh screen sandwiching it in the main box. The intake for thd filter is routed inside the passenger fender (its a long snorkel). Its a lot of plastic and it is nice in a way, but I went to a Steeda Cold air intake which gave the engine more pep and you can clean and change filters as you desire.
It's a pain you have to take off the wheel and wheel well cover to get to it all. It's insane how long it is, it ducts all the way back to the driver's side mirror for the intake opening, hidden in the fender. I cleaned it out the best I could and left a few inhibitive parts off, it helped. (2ft pipe and bs screen before maf) The wheels chirped the first time givin' it the beans then the computer quickly regulated any fun out of it for the sake of the transmission.
A super common problem that there is no easy fix for...the recirculation door. A lot of people think the fix is a new motor, but it's not. The plastic gear strips out and you can try epoxy, but the only real fix is to replace the whole heater box inside the cabin. Assuming you find one in a junkyard that didn't fail yet. I just leave mine on recirculate and reach inside the glove box opening if I need to switch it manually.
√ *Watch the Video*
√ *Buy The Part at 1A Auto* 1aau.to/m/Visit-1AAuto
√ *Do it Yourself*
√ *Save Money*
i have all these problems one by one lol to december 2015 to january 2019
7 Ford Focus air conditioner lines
But you didnt mention the imrcv (intake manifold runner control valve) aka swirlflaps that retard air flow at low rpm for fuel efficiency. Eventually wear down. If one flaps falls before you fix it' it falls into the cylinder which causes catastrophic failure. Great video other then that. I have 07 zx3 five speed. If you could do a video addressing a perma fix. zx owners would owe you 1. Ive heard you can take the flaps out put back bearings and main rod as to not get a check engine but also eliminate the risk of motor dieing.
Where can I pick up motor mounts?
+Shannan Cook You can order window mounts through our site 1aauto.com
On my 2003 and 2007 Focus, I've gone through 5 engine mounts so I can vouch for #2. The 2003 also had the ignition core go out. 2007 had a bad alternator too, so I'd say this video is spot on!
God these cars hate their motor mounts. Still waaaay cheaper than a car payment in 2021.
Mines getting a RWC atm and possibly needs a engine mount
Me too on my 2000 Focus. I gone through one mount. How many mounts does the Focus have?
I just bought a 2007 Focus with 175k miles and it shakes like nobody's business. This video was so helpful, just ordered the motor mount and transmission mount kit from 1A, looks easy enough to install!
I have a 23 year old 1.6 Ford Focus manual. 181000 on the clock. Still has the original alternator, water pump and radiator. Never had any problems with keys in locks, electric windows and no engine warning light on. It's a great car.
Just bought a 2004 Ford Focus wagon, 181 on the clock and $1000 from someone who wanted an upgrade. First car I’ve had with zero rust. Had this as my first car 6 years ago and loved it. Changed the motor mounts so in the future it’s a easy change for the new car. Really excited for this baby. Basically a mini mini van with 28 mpg.
great! who asked?
As someone who has owned a 2002 Ford Focus for 10 years, these issues are all too accurate. I’ve replaced everything mentioned at least once.
Great video
Kamal
HAHAHAHA! I just bought a 2005 focus for $500, I swear it has at least 3 of these issues. We'll be in touch...
Our 2007 focus 3dr hatchback has been a great running car.
We purchased it used in 2009 with just under 40k miles it currently has 133k.
Normal Maintenance has been front and rear brakes, rotors, drums, tires, ac top off, oil changes, and coolant flush.
I have replaced the driver door locking actuator, both lower control arms due to deteriorating bushings, a muffler.
I save a lot of money by doing all of the repairs myself.
It seems the Focus is a good car if the only things you have to worry about are these common issues. Seems the engine lasts a long time.
My original engine is now hitting 300,000 miles. I have transmission problems but it is a junkyard replacement Transmission with 200,000 miles on it. Some were very HARD MILES meaning I lived 2000 feet up a mountain and had to drive it daily for around 3 years of the life of the car.
Keith Wao,,I Have A 01 Zetec With 206,000 And Running Strong
It's a odd beast, most of the time the first gen of a car is the absolute worst for reliability but the first gen Focus is the best focus for reliability, they started going downhill after until we got the current one with that shit transmission
The zetec engine they put in those is damn near bulletproof, I've owned three of them and I beat the living snot out of them and they willingly take it. Only issue I've come across was a tiny leak in the valve cover gasket on one of the three, the other two have been just fine
@@deejaydfc after 250.000 km and 17 years still 14 bar compression. Im kinda impressed
Have not had any of those issues with my 2007 Focus.
Most bothersome issue is wheel bearings: Have done 3 wheels so far.
Next is oil in spark plug wells, so replace cam cover gasket.
That's about it. Still going strong right now with 123K miles on it.
I second the cam cover gasket. Otherwise, all good at 175K.
Yeah my motor mount was replaced right away. My drivers window was also repaired. I have a 2000 Ford Focus. The car runs great at 20 years young.
+LadyCMitchell13 Thanks for checking us out! 1AAuto.com
Great video! NYer here. I have a 2001 hatchback Zx3 with 262,500 miles. MANUAL transmission. It's still going strong. It has the window regulator issue on the passenger side, but it hasnt completely stopped working yet. Today I couldn't get the key to turn. It took me about 15mins and 3 dozen attempts to get it cranked over. It also has that bogging out issue with fuel pump. Other than that very reliable car and fun to drive.
Thanks to your videos, my 2003 Focus with 200k miles almost stopped leaking oil and coolant!
Hes CORRECT about the motor mount. I bought my 01 ford focus 5 months ago and i had to replace the motor mounts twice! And the ignition part where my key always gets stuck and wont turn! Thanks 1A Auto, i love watching your videos! Im a woman and all these videos are very helpful for me, when it comes to fixing my car!
I have a 2002ford focus as this helps out a lot. Thank you
We are glad to hear it Michael! You are welcome
09 Focus over here. I've put the original 54k miles on it. I hope it lasts forever! Everything is original on the car except the transmission fluid, engine oil, tires, motor mounts and AC evap. It's a good reliable car so far.
I respect your beard. Sincerely, my beard.
I just recently got a 2002 ZX5 from a police auction with 206k miles for $910 and MANUAL TRANSMISSION which is the MAIN REASON I got it (they are getting HARDER to find). The key thing is something that I did have a problem with from the get go, I lubed EVERYTHING possible that may not been done in GOD KNOWS HOW LONG. The oil was quite clean and SURPRISINGLY everything important appears to work ok even the cruse control.😯😁 It RUNS PRETTY GOOD, have to restrain myself from ZOOM ZOOMING to much because it RUNS SO WELL especially because of the manual transmission. It actually handles pretty good as well, need to replace the tires in the reasonable future because when it rains and if I'm speeding a little it does slide a little but not too much but enough to keep me from pushing it too hard in the RAIN. It holds the road GREAT when the road is DRY. IT HAS PUT THE FUN BACK INTO JUST NORMAL EVERYDAY DRIVING.😄👍😎
Good Video. Thanks! As a professional locksmith, the main reason the ignition swithc goes bad is from people who hang a ton of crap on the end of it. It pulls down the rear, tips up the tip and wears things out. Also all locks in American cars are made with brass pins or side lock wafers. If you are not using a brass key, you are wearing out the key AND the lock.
Also those window motors ? OMFG what a Byzantine bow string winding cable confusion those are!!!
+Steve McLaughin Thanks for the feedback!
I absolutely love you all for helping me to be able to figure problems out. I just bought a 2007 Ford Focus 163,000m for a $1,000. First things I notice is there's no defrost and the windshield wipers don't work. I hope I paid a good price. Oh and engine light is on so I'm trying to get that to turn off before I even go to inspection.
Very accurate my dad used to have an 03 Focus and we replaced every single one of these parts mentioned. Some of them even multiple times with that said though it was a great little car had 270K when he got rid of it, and still ran like a champ.
+Dustin Venditti Thanks for checking us out!
@@1AAuto Thank you for all of the informative repair videos! keep up the good work!
Key stuck in the ignition fix. Below shifting knob is a plastic tube running down through the console. Gently pull up on that tube and release. Problem solved. Worked for me and hasn't happened again in over a year. Love your tutorials. Thank You.
You're adorable! Thank you for the helpful video! Im on my second ford focus wagon; I love them! And yesterday the ignition went on my new focus, but I knew how to fix it! I saved myself a lot of money by drilling out the ignition tumblers, then using hot glue to secure my key inside the drilled out casing. So, basically, I just claimed this car as MINE, for the rest of its life!
I have the problem with the key getting stuck in the ignition. My friend came over and showed me a trick to get it out on my 2007 Ford Focus. She moved my shifter You can shift it from park to anyone; drive, Nutural reverse, etc. then pull the small plastic ring on the shaft (just below your hand). Pull the ring up sometimes I have to turn it now that I have been doing it for so long. Put it back into park and try to see if it releases your key. I sometimes have to try a few times. It happens every once in a great while. So I haven’t found the need to get it fixed. Hope I explained it well. I am no mechanic and not mechanically inclined by all means if u can’t tell lol I just wanted to put this out there. If it wasn’t for my friend showing me I would have been screwed with having to leave my key in the ignition and having to pay $$$ when I didn’t have to for anyone who can’t afford and save the money for other repairs (maintenance) on my vehicle.
I don’t recommend anyone driving my vehicle without me in it to explain the different things u may need to know or u may not depending on my vehicle that day 🤷🏽♀️ it can be a bi bipolar like it’s owner 🤦🏽♀️
I love this site. Number one...he keeps it brief. Most go on and on and there are more ah's and ugh's than spoken words. Video quality is excellent, you can watch the repair and see what is going on, so many don't cover the entire process because the camera light source is not enough. I trust what I can see as it is being explained or performed at the same time. I go to this site first, always.
Hi, I've had my ford focus zetec mk1 hatchback for 11years now in England, and I've had no problems at all with the issues you've mentioned, I must have got a really good one when it was built in 2004, but thankyou for the video, at least I'll keep and eye out for any of these problems, should they arise, I watch all your other videos, they are very informative and you make them easy to follow, so keep up the good work,
I got my with 30k now has 142k.
Fuel pump changed on my at 130k
Engine mount at 120k
Window regulators 2 times changed
Key never had an issue
Alternator never changed
Im at 170k and car is down got a new alternator just gotta put it in already put in a new battery and havent need to do any of the rest although i should replace suspension but is the car really worth it at that point? Knock on wood I dont have any issues with the fuel pump
Just watch out for when you need an alternator. If you still haven't replaced your alternator, I'd keep some flares in your trunk. When the alternator goes out, your battery will die leaving you with no lights. Nothing to freak out about, just be warned.
Thanks for that info. Looking into buying a 2007 Ford Focus Station Wagon at 190K miles
The problem i had when i got it was coolant leaking where the thermostat is at. As the part is made of plastic with heat being in the mix. Exterior part starting to come off like rear view mirror. Other than that just keep up with the fluids and filters.
@@joelvarelajr6495 Lol coolant recently started to leak for me, also the plastic coming off I had an alternator problem, broken bonnet lock, most annoying thing is instrument panel going bad with all engine, esp, acceleration reduced errors, rust does to my countries weather and use of salt (had rusted hole below driver seat) also changed the starter. I am thinking to get rid of my Ford Focus 2007 besides at my country local craigs list alternative portal is full of FOCUSes for spare parts........
I've experienced the windows and fuel pump issues.
Other common problems on these are the speedometer going mad and AC blower motor resistor fail.
Brilliant cars otherwise.
My speedometer goes crazy too! I thought its from overcharging battery, which could be due to voltage regulator inside alt. Did you fix yours? Or do you know the certain 'cause of it?
@@jeaniejpeck-barge5778 Bit of a late reply. Its the speedo sensor that's faulty. I've had 3 Focus' and 2 have had the exact same issue. Cheap part and easy to do after watching a few videos...
Ac blower motor resistor? What does that do and how do I know if it's bad?
i have a 01 focus zx3 i have had since i graduated in 01 i can attest to all these things , and right now im currently in the process of replacing the fuel pump and filter
Hey I’m actually looking into one of these cars right now and I’m doing research on whether or not to buy it. Would you recommend it?
Don't forget the EPFS(Egr Pressure Feedback Sensor) and the Crankcase Emission Breather hose...the first one connect to two metal pipes via two short rubber hoses...the parts from the sensor that connect to the hoses are plastic and tend to crack overtime due to heat...#2 is a little hose that connect to the crankcase vent system and is located behind the intake manifold...it become to soft overtime due to the heat and tend to strangle...both things when bad can cause the engine to stall very badly and sometimes lose power or turn off.
+DragonWarrior Thanks for checking us out! 1aau.to/m/Shop-1AAuto-c
dang. i've had my 06 focus since 2008 and have not had any of these issues. i guess I should be thankful.
The only thing I replaced on my 01 zx3 is the thermostat housing on mine
I bought a 2006 Focus new and have never had any of these issues. The biggest issue is that the "sonic blue" paint falls off. Second biggest was the engine control module went out after about 5 years but it was still under warranty (although the car was only a 3 yr/30k warranty). Had to replace alternator, thermostat, battery of course, fuel pressure sensor, plugs of course.... it's been a perfectly reliable car, despite what numerous Toyota fans told me. It's been my daily driver for 15 years plus several cross country trips and has never left me stranded.
Oh and replaced the vent selector cable which is evidently the experience of just about every Focus owner this generation.
I've never had things explained better. Keep up the good work.
+Uh Really Thanks for checking us out! 1aau.to/m/Shop-1AAuto-c
great video very accurate. i've got a 2003 ZX5 that i bought new. 165.000 miles on it now. I've had to replace the driver window regulator , alternator , engine mounts and i've had to pull the ignition switch and just remove the tumblers. only other thing i would add would be i've had to replace the thermostat housing twice. they are plastic and crack. All in all it's been a great car.
+John Priddy Thanks for checking us out! 1aau.to/m/Shop-1AAuto-c
I have a 2005 Focus with 175K on it. It's been a great little car. It's still kicking.
My 07 worst problem has been the idler pulley bolt breaking. After the 3rd time I drilled and tapped the hole to 1/2 and used a grade 8 bolt and it has not broken since.
Technically ,a great Car after all!
so glad someone finnaly made a video about the focus. there is not much I dont know about the years from 2000-2005
+JOE Hyundai Tech Thanks for checking us out!
That was EXACTLY what I needed to see AND when I needed to see it. I've been at war with mine for bout 2 years and think I've put MOST of these common issues behind me. Somehow even with all of the NEARLY back to back or reoccurring issues I'm addicted to this thing. Never thought a roller skate would be this much fun to drive. Would like to KNOW what may be ahead for me here so JOE Hyndai Tech if ur still around I think thst I would like to communicate with you if you don't mind.
@@darinstocks1184 so sorry for the delay Darin I never checked back for my messages until now I have been so busy.
I have had 4 Focuses (2001, 2003, 2007, 2005) since my first one back in 2006 and I've had incredible luck with each one of them but I definitely had the motor mount issue on all of them, as well throttle position sensor issues on the first three and an idle air control issue on the first two. I love these little cars and always end up regretting trading them in. Recently, I decided to get a back-up vehicle so I found myself a 5 speed 2005 full of all the "bells and whistles" with only 100k miles (my first hatchback/two door) on it in amazing shape for super cheap and don't plan to ever get rid of it. I actually got my second Focus up past 300k miles before selling it (four kids, needed a third-row SUV) and not once did that car let me down so I've got high hopes for my most recent purchase, being that it has such "low" miles on it. I'm not a Ford guy by far but I can honestly swear by these extremely dependable little cars.
Also, Focuses are already pretty buzzy and vibrate more than most four cylinder cars, but it's definitely magnified when the mounts need replaced.
I've got a 2001 zx3 since 2011 and mileage is 255600 and it gave me problem recently with the transmission ! I put Lucas in the transmission and it certainly has given my car another chance and a second wind as the acceleration grows and grows! Lucas is like a mechanic in a bottle! My mechanic told me he didn't want to work on it because he just knew my transmission was gone! Now he's surprised because I'm asking him questions about another problem because he thought the last problem the Transmission killed the car adventures! Not so! LOL
“Verhicle”
Fer reals, lol
I thought i was trippin
Right lol
It's VEERICLE. Like icicle but with no ic just veer.
😂😂😂😂😂
Have had most of these problems on my 2001 Focus wagon. Have not had any problem with ignition key, keep it lubed with spray dry lock lube. Fuel pump gave up about 4 or 5 years ago, was replaced by Ford for free, caught fuel pump recall in its last few months! Motor mounts need changing every year or so if you use the cheap ones, (Arrow), from parts stores, use oem parts on this. Window regulator cables broke on left rear door, other doors OK. Bigger problem is all four door handles broke, small pot metal part breaks on handle reinforcement, only metal part and it breaks! Alternator, on third one, used local rebuilt part and it dies after one year warranty, used pro rebuilt alternator the last time- no problems!
What spray did you say you use for the ignition key?
You are spot on. I have been playing with my keys getting them in and out of the ignition. I have a 2005 focus. Zx3. About 220,000 miles and still runs like a champ though. Great video.
+@Chadkrivec Thanks for the feedback!
Those are exactly the five issues that I've had with my ford , thanks for the video.
My dad drives a 2005 Ford Focus and it's been a very good car for him, his is a bare bones model with 5 speed manual and manual windows/locks.
+Doobie1975 Thanks for the feedback!
I don't have a ford focus but still good info
2007 focus has problems with valve cover gasket....fails and before you know it the spark plugs are submerged in oil
That's one of the early Duratec ones. All the early Duratec motors had a whole set of extra issues. The Zetec motors were a rock-solid design, largely perfected on the original Escort platform.
yeah I replaced the gasket on my 2006. Not too big of a deal.
I found a common issue with the focus is the thermostat coolant housing cracking all the time
Yep, replaced mine twice already.
Yep its because it is made of molded plastic and they split at the seam. Not like the good ole metal housings.
My first car was a used 2005 Focus ZX3, had it since 2017. Literally the moment I bought it from the previous owner I switched on the head lights to drive away, an electrical fire broke out. Quickly put it out and the owner had the electrical issue fixed a week later. Only reason I didn't back out of the deal was because the car had 65,500 miles on it
Dealing with my ignition cylinder right now. Thanks to you I now know what it is. Who to get to fix it is the challenge now! Thanks for your help. Great video!
I got a valet key for 2$ taped old key by ignition. Works. Thought was cylinder just worn key
Excellent video. Thanks. Our 2000 Focus SE has some of these problems, including the stuck ignition key (7:13). A temporary fix is to gently tap (toward the steering wheel) the end of the key. We keep a hammer under the driver's seat.
I have. 2006 Ford Focus, 184k miles and it's been a fantastic car until this year, 2024, when it started to have one issue after another.
I'll be looking at 1 of these later today it's good to know what to look out for
same haha
Ive owned an 02 ZTW Focus Wagon for many years and for years have been wanting to upgrade and fix alot of issues..and finely found the time and money to do so! So Id say within the last 6 months, you name it and chances are I've replaced it. Long story short?.. I don't know what I would have done without the 1A Auto videos. Seriously, I have been very successful at fixing our Family Focus Wagon and I just want to say thank you..Especially to the gentlemen in this particular video. I'm horrible with names..(I call you the bonk bonk guy) lol. Hands down you do a wonderful job. Keep doing what your doing sir.. and Thank you!
+Heath and Val Hutchinson Thank you! We love empowering our customers and showing how to perform DIY auto repairs with our high-quality auto parts. 1AAuto.com
Just bought a 2007 5-speed with 190000 Miles. Body was solid. Power nothing which is great. Less to fix. He wanted 26 and I got him down to 23 hundred. Great running car and thanks for the info on what to look for going bad.
Just got the exact same car, 191k miles. Did the valve cover gasket, spark plugs and new battery. Bought and got it running for under 900
I love mine. Had it for a year. 175 k and runs nice. Gonna change some tie rods and links and look at the steering pump. Other than that minimal work and I love it
Easy to understand, enjoyed listening
"One foot on the brake and one on the gas" "There's too much traffic I can't pass no."
+Sooleman Thanks for checking us out! 1aau.to/m/Shop-1AAuto-c
Thats what I thought of too. Sammy Hagar's I can't drive 55!
the #1 issue with the 00-04 focus was the SPI engine dropping valve seats. probably not a problem for any cars left on the road because all the SPI cars are scrapped by now. zetec and duratec engine options were bulletproof
+Michael Larson Thanks for the feedback!
I think I'm the only person that manged to blow a zetec motor
@@_Boobz you revved too high
Well I started buying alot of my parts from 1A auto because auto zone and such always send me the wrong part for my v8 impala. They always give me a v6 version and they don't fit at all. But you guys haven't let me down
+Juan carlos Garcia Thank you for your order! We'd love to hear about your experience. Here's a link to leave us a review on Google: goo.gl/i5JFNY
This was extremely helpful, nobody could find the cause of my car shaking and stalling. My check engine light has been on for months, so many me panics and wasted time and money, thank you very much!
You forgot to mention the valve cover gasket! If you see oil on top of the spark plugs when changing them or smell oil burnt oil when driving it could be the valve cover gasket. Don’t worry it is a very easy and cheap fix! I own two focus’s, a 2011 sedan and 2007 hatch. Great cars!
When your alternator died while you're driving just check your footbreak immediately before the footbreak's gone..
It's not what I know, but who I know that gets me to where I need to be. It's who I know that translates into what I know. Thanks for taking the time to share with us your knowledge. Knowledge is good with an inheritance, and by it there is profit under the sun . Can you imagine if someone like Newton or Einstein had never shared there knowledge ? We'd be left guessing in the dark about the mysteries of the universe .
Dude, u nailed everything! Every single thing youve talked about, ive dealt with (or am in the process of dealing with)! Subscribed & thank you for ur knowledge
We have a 2007 Focus and it's a trooper. > 200K miles on it, and it still runs like a top. The only one of these issues we've seen is the alternator (but we've had to change it twice!). Now I want to check the engine mounts though, because it does seem to vibrate a lot when idle. (It's never been the smoothest running car, so I guess it never occurred to me there might be a problem.) We also cracked the steering rack on it, but that was... uh... operator error. 🙄😁 Thanks!
I had every problem you listed plus many more on my 2000 focus. First new car...good times lol
I owned a 98 plate and never had any issues was great car. Then bought an 06 titanium no issues and now im on a 17 plate titanium x, all good so far.
Great video clear and concise friendly and informative. I'm sick of being ripped off n lied to or of the assumption I know nothing about cars ? Thanku your my mechanic now cheers
+Jo Hackston Thank you! We love empowering our customers and showing how to perform DIY auto repairs with our high-quality auto parts. 1aau.to/m/Shop-1AAuto-c
I bought a 2002 Ford focus zx3 bare bones with a manual transmission. It was a relatively reliable car, but I've had the fuel pump issue which eventually went away and was never replaced and the ignition cylinder, which was replaced. I've also had the valve cover gasket leak which I replaced, the catalytic converter which was replaced, then the AC blower motor went out before I sold it. It had 174, 000 miles before I let her go.
excellent video thanks. On our 2003 manual Focus we have to replace one or both of the front anti roll bar drop links every year as we have awful country roads in the UK. Another common fault with these cars seems to be that the coil packs split causing misfire under load.
+John Cooper Thanks for checking us out! 1aau.to/m/Shop-1AAuto-c
I've experienced every one of those problems! So ironic lol. Also my back hatch sometimes doesn't close quite right which leads to dead battery the next day.
Very helpful. Thinking about selling my 2001 Focus. I will have to give it another thought!
+Gerysann Photography Thanks for checking us out! 1aau.to/m/Shop-1AAuto-c
Thank you - we are just getting our free ZX5 on the road after it sat for a couple years.
That's funny.. I just got a free zx3 and its idling rough as hell to the point it dies and I need to replace the master cylider for the clutch. Been off the road 3 yrs I'm told
@@Rider_2013_ Spark plugs may have fully fouled over that amount of time.
It's the plugs or distributor.
I got Focus 2001 Ztec actually runs 215,000 miles and counting, about common faults yes i be experienced alternator, window elevators (4 doors) and motor mounts, the rest no problem yet, excelent car if you take care and give good preventive maintenance.
+alberto lopez Thanks for checking us out. Shop for high quality auto parts on 1AAuto.com:
1aau.to/m/Shop-1AAuto-c
Very interesting. I am doing motor mounts on my 08 ford focus SES. Also the power steering pump and high pressure line.
My mother owned an 03 Focus from 2004-2016. Was a solid reliable car. I have so many fond memories in that thing. If it wasn’t for living in the damn Rust Belt we’d still be driving it
My alternator went out in my 04 svt. I drove it that way for 6 months by plugging in to a battery charger every night. I could drive it to work, out to lunch and home no issues. Maybe total of 10 miles a day 5 days a week.
I had a 1990 Geo Storm and it lost the alternator belt on a long trip and never gave a problem even night driving for 2 days until I replaced it. That is reliability for you.
Perfect. I am looking at a cheap used 2005 wagon that has 3 of these problems. Good to know common problems with common solutions.
I was afraid 2007 fell under the 1st Gen. Thanks for this video. Shed some light on the shaking and loss of power with the 1st 2 problems. People trying to get me to buy a new transmission lol. Gonna hope it's just this and save up to pay for repair
The motormount that is at the front of the engine under the coolant reservoir. is a liquid filled mount and they frequently go bad. and the ignition switch, if a person is having a problem with removing the key from the switch. they might check the shifter because they have a safety incorporated in them. that won't let you remove the key unless the shifter is all the way in the park position. of course that pertains to automatic transmission models only.
as usual great video. weve used 1a many times and most helpful
JUST BOUGHT ONE, HAD THE WINDOW ISSUE HAD FIXED, WENT AHEAD AND DID THE MOTOR MOUNT. OVERALL I THINK ITS A GREAT CAR I LOVE THE WAY IT DRIVES. JUST A LIL TRIMBLE ON TAKEOFF OR IDLEING BUT I THINK ITS WILL DRIVE OUT FROM SITTING AWHILE GOOD INTERIOR BUT DASH BOARD LIGHTS ARE DIM ANY SUGGESTIONS. GREAT FOR MY PROSTHETIC LEG GETTING IN AND OUT OF AND LOTS OF ROOM FOR WHEELCHAIR IN BACK HATCH OF WAGON. THANKS FOR SHARING YOUR VIDEOS I LOVE WATCHING AND LEARNING SKILLS
This video just helped me a lot thanks
+Mike Thanks for checking us out! 1aau.to/m/Shop-1AAuto-c
Very helpful. I’m looking into buying a 2007 Ford Focus Wagon in a couple days and this helped me to know what to expect that could become a problem
Before you replace the ignition cylinder, make sure the plastic sleeve around the gear shift hasn't dropped down into the console preventing it from going into park. I've had this happen a few times and the result is you can't take the key out. You can just push it back up into place.
I work on many of these ford focuses from 00-11 mostly work on the 2.0 duratecs. there are many common issues that are not listed in these videos.
-Valve cover gasket, the seals around the spark plug holes give out and will leak into the spark plug hole, usually it doesn't cause an issue but if you go to do plugs and find oil then you know the vcg is due for a change.
-front lower control arms, these have a tendency to rot out because if the design, and the rearward bushing is a common part to wear out.
-water pump, very common for the bearingon the shaft on the waterpump to start letting coolant through usually doesnt leak enough to be noticeable unless you're specifiaccly looking for it.
-Rocker panels, from 00-11 ford used some chip guard paint on these rockers, if you live in the rust belt then you probably see alot of focuses with rotted rockers, the chip guard coating they use traps moisture and they rust from the inisde out usually.
-08-11 focuses tend to have the front calipers sieze alot more than the other years.
I have ford focus 2005 zx4 ses 180.000 mile and still runs really good never have any issues
Like to thank you for joining my memory as I completely had a brain fart yesterday felt clueless, sounds daft when I passed my level 2 mechanic last year
I've got an 02 focus 1.8tddi for 9 Years now. Great cars and no seriously issues so far except for an oil cooler failure.
I've owned 7, MK1 ford focus, their great cars overall, yes, the cheaper motor mounts are an issue, as the aftermarket ones only last a year or two if you're lucky, as motor craft (OEM Ford product) does not make them anymore, and those were the best at the time, as you'd not be replacing them as often.
The ignition key tumbler issue is also exacerbated by heavy keys on your key rings, as it will warp the tumblers in the cylinder, causing the issues mentioned in the video.
The alternator wiring harness usually after 5 years or so will eventually corrode due to age and the wires will sometimes fall out of the plug ends of it, and replacing it is the only solution, as the early warning sign of this is the battery light flashing every so often to tell you the battery isn't being recharged, if you ignore it will eventually stay on once the battery warning light stays on full time, and you will kill the battery if you don't replace that stupid harness.
As for the fuel pump, it was an issue in the first model years (2000, 2001, 2002) where there was a recall by Ford about this, the other issue related to the fuel sputtering issue is a clogged fuel filter, as that is also something that needs to be changed every 50,000 kms / 35,000 miles as it will clog up and cause the same issues as the bad fuel pump, there was a TSB about this issue in 2002 / 2003 for the earlier model years and the fuel pump recall was for all focus's from 2000 till 2002.
my right side motor mount went out within 3 months of replacing it :)
2000 ZX3. I've replaced the ignition cylinder, alternator, battery, ac clutch(without removing the compressor or losing the 134a), motor mounts, hatchback latch assembly, front struts and springs, exhaust hanger, timing belt, serpentine belt, and maybe a few other things I can't recall the name of right now...but the intermittent check battery light is the one thing I can't seem to beat.
Just sell the vehicle, I replaced all those things to & the engine still blew out. I should have sold it. & bought a Toyota. Spent 2,000$ on the vehicle & 6,000$ trying to fix. Worst vehicle ever.
Ok,you said leave you a comment...
Video was Very good,and your explanations of why and what to do is clear...thank you
You’re legit mechanic if you can replace the alternator, I won’t even try, it’s weighed in therelol
You are right about the engine mounts. Mine is a '06 and a resppecfully 305000 kms...consume no oil doesnt leak and everything works. Even tha a/c...nice vidéo thanks!
I just purchased a 2009 Ford Focus. It only has 47k miles. But today I noticed the back window won’t go down, the engine shakes like it needs a motor mount, and I replaced the battery after the first week I owned it. Looks like these are common problems with the Focus.
Have an 07 focus and would love to see a video on the "lifetime" air filter/ air intake because its impossible to find anything on it
+Br0k3n W01F We're always cycling through common cars. We'll add this repair to our list! 1AAuto.com
I’ve owned an 05 and 07 Focus. Doorman makes an air filter housing that uses traditional air filters that you can swap out.
I actually replace mine in my 2007 Ford Focus Zx3. It literally is sofa foam in a sealed box wih a plastic mesh screen sandwiching it in the main box. The intake for thd filter is routed inside the passenger fender (its a long snorkel). Its a lot of plastic and it is nice in a way, but I went to a Steeda Cold air intake which gave the engine more pep and you can clean and change filters as you desire.
It's a pain you have to take off the wheel and wheel well cover to get to it all. It's insane how long it is, it ducts all the way back to the driver's side mirror for the intake opening, hidden in the fender. I cleaned it out the best I could and left a few inhibitive parts off, it helped. (2ft pipe and bs screen before maf) The wheels chirped the first time givin' it the beans then the computer quickly regulated any fun out of it for the sake of the transmission.
Ah, those poor Duratecs.
Pretty Good video, watched all of it. A lot of interesting things
A super common problem that there is no easy fix for...the recirculation door. A lot of people think the fix is a new motor, but it's not. The plastic gear strips out and you can try epoxy, but the only real fix is to replace the whole heater box inside the cabin. Assuming you find one in a junkyard that didn't fail yet. I just leave mine on recirculate and reach inside the glove box opening if I need to switch it manually.
Got my '04 Focus ZTS two months ago. From what I know, the alternator has been changed before I got it.
These videos are cool asf!!💯 Aswell as helpful very helpful. I'm learning a lot through A1 auto man much respects and God bless
Tenho dois Focus 2001 e 2003 não tenho nada a reclamar... melhores carros que já tive... ótimos carros principalmente pra viajar 😃