tata indigo fuel injection pump setting in detail | how to set fuel pump | increase mileage
Vložit
- čas přidán 2. 07. 2019
- tata indigo fuel injection pump setting in detail | how to set fuel pump | increase mileage
Hi, I am Saourav Kumar from INDIA
*To Follow me on Instagram
/ saourav_kumar_gajnet
*Facebook page link:- SaouravKumar...
*Facebook group link-- / 2621080847965716
*Fuel-Injection Pump Part-1:- • tata indigo fuel injec...
*Tata indigo smoke level at 5000+ RPM video link:- • 5000 RPM no smoke solv...
*Silencer cleaning video link:- • how to remove Black Sm...
*how to clean EGR video ink:- • how to clean EGR with ...
*high pressure fuel pump sensors- cam-valve sensor, solenoid-valve sensor & TPS sensor video link- • high pressure fuel pum...
*Facebook page link:- SaouravKumar...
*Tata indigo injection pump setting to get maximum mileage and lowest smoke and high pickup and it helps to tune up the engine and its sound. also helps to reduce black smoke from exhaust and helps to increase engine life.
mainly rpm is very difficult to set after 50000km manually but my video will help you.
*some extra knowledge:-
Primary Functions od IDI engine with ECU:---
1. Fuel pump injection timing control.
2. Glow plug pre & post heat control.
3. EGR system on-off control.
Secondary Functions:---
1. FICD (Fast Idle Control Device Control). This is
the device which
increases the rpm when the AC is switched on.
2. AC switch off at high Engine temperature and high
loading.
3. High altitude proportional control.
4. Fault detection & storage of trouble codes.
The ECU gets its inputs/information about Throttle
position, coolant
temperature, ambient temperature, engine rpm,
crankshaft angle & Injection
start from the following sensors on the engine :
1. Throttle Position Sensor or Fuel Level Sensor :
This is a potentiometer connected to the fuel delivery lever which is
actuated when the accelerator
pedal is pressed. It sends a DC voltage to the ECU which is proportional to
the accelerator position.
2. Temperature Sensor: This is a thermistor type of
sensor, monitoring the coolant temp.
3. RPM sensor: Part of the alternator. Gives 3
voltage pulses for one revolution of the crankshaft.
4. Crankshaft Angle Sensor or Crankshaft Position
Sensor. This is mounted on the flywheel housing and provides piston TDC (Top
Dead Centre) information to the ECU, in the form of a number of voltage pulses
per 90 degrees angle of rotation.
5. Needle Lift Sensor: This sensor is part of No. 4 cylinder fuel injector,
& sends a voltage signal to the ECU at the precise beginning of injection.
tata indigo fuel injection pump setting in detail | how to set fuel pump | increase mileage
How it works :
Based on the inputs from these sensors, the ECU
controls the following units
through Relays, Solenoid switches & PWM control :
1. Glow Plug Heaters: These are for pre-heating the
cylinders. The ECU controls the glow plugs ON time based on ambient &
engine temperature.
2. Fuel Pump: Injection timing is controlled depending on the position of
the accelerator pedal----timing is advanced automatically at higher rpm. The
ECU controls a cam actuator inside the fuel pump,
based on a look-up table stored in the ECU program ROM.
3. EGR: This is the Exhaust Gas Recirculation
system. Part of the exhaust
gases is mixed with the air intake to reduce temperatures inside the
cylinders to below 210 deg C., which sharply
reduces the formation of Nitrogen Oxides (Nox) in the exhaust, thereby
reducing harmful pollutants as reqd. by Euro / BS 2 & 3 norms.The EGR valve is
controlled by the ECU, & gets activated in the rpm band 1100 to 3000 rpm,
with small variations to compensate for engine temp & loading.
4. FICD: The fast idle control is used to increase
the idle rpm when the AC is switched on. The ECU activates the FICD through a
solenoid switch by monitoring the AC compressor clutch voltage.
The ECU also continuously monitors the engine
temperature, & switches off the AC if upper limits are exceeded.
All the sensors are also monitored continuously, and
a fault or trouble code is stored in non-volatile memory in case of a
fault, & the Check Engine Light comes ON.
IF THIS VIDEO HELPS YOU DON'T FORGET TO LIKE & SHARE THE VIDEO & ALSO SUBSCRIBE TO MY CHANNEL
I film, edit and publish each video on my own.
I have had many viewers comment and let me know how I have taught them how to fix their car themselves and save them $$$$ and I love it!
thank you.
#fuel_injection_pumo #heigh_pressure_pump #simple #Hindi #CarProblem #Best_video
#crackover #crack_over - Auta a dopravní prostředky
Waaah bahut aachhi tarah samjhate hain aap,Thanx🌹
Thanks sir 😀👍😊
Cont nb plz
If your technique is followed, there is a high chance of overheating of the AC compressor. AC compressor can be overheated if the setting is done with less rpm tolerance. The process is little risky when concerned with AC compressor with frequent start-stop action. I hope you get the point. Nice explanation. keep up the good work.
Thanks for the comment Sir
Yes sir you are correct but this will happen when your cars engine is over heated also AC is continuously working for 30 to40 km or for 45min.
Yes it may happen but with proper saftey the chances for getting trouble is 2% to 3%.
My car is 10 year old but currently it is giving 17 to 18 milage on Highway with AC. If fuel is good.
Thanks you
👍👍👍Thanks for the comment Sir
👍👍👍😁
❤️Thank u so much brother❤️
Aapne jo trick bataya hai ..Jaisa aapne bataya waisa karne par ...Meri car ka problem solve ho gya..
Thanks for the comment sir
😁👍❤✌✨✨
Nice video & information bro, Jai Hind Jai Bharat
👍👍👍👍👍👌👌👌👌👌bhai aap bahut achha shamjaya thanks
Wah kya mast samjhaya aapne🌹🌹🌹
Thanks for the comment sir
🙏😄❣️👍
Thanks bro very nice video.
Thanks for ur video bro, from kerala..🙏
Thanks 🙏👍
Good job sir 👌👌👌👌
Nice information bro
Very nice video. Well I have 2005 indigo it suddenly does not increase the rpm on ac on
And now in winter I have found the choke which usually in winters in kashmir increases the rpm for few minutes is not doing so and my car which usually starts on 1 self is taking few self's. I have checked heater plugs which R fine. Please suggest
I think my ficd is not functional
Very. Nice. Explain. Bhai. Sab...Thanks
Thanks for the comment sir
😁✨❤😁✨✨✨👍
Very useful information
Nyc bhai 👌👌👌👌
very good my brother
Bahud sahi he I liked
Bai 1 no yar yahe problem kabse solve karna chahata tha
Good message bro
Thanks for the comment Sir
😁👍🙏
Nice vdo
Hi your showing Ac ajjesment for pickup and mileage .but my dout and questions is if adjusted is done than the ac cooling will be not effective...
Thanks sir ji.
Thanks for the comment Sir
waiting...
Bro perfect mileage setting
Same process or setting pe bhi best mileage ayega😃👍
Very NYC video sir
Bhai ji aap ki video dekh kr acha lga ak help chaye mere pass mandra bolero h di mtlb rotary pump vali h uska fuel set kse kru please btaye
Thanks for the comment sir
Ji ap mujhe watsapp pe pumo ka photo bhejyea main dekta hu.
Mere pass vista tdi hai aur uas mai wo ac cutoff wala screw full open kark accelerator se idle rpm set kiya to jyada mileage degi kya?
Sir 1 No
Thanks for the comment sir
✨✌❤✨✨
Sir konsi obd tata indigo ecs lx tdi 2011 dicember keliye sopport lega
Gooood 👍👍👍👍👍👍🌴💞🌴💞🌴
Thank you Guruji
😀😁
Me aap ke sab video dekhata hun or download karata hun
Make a video on Indica v2 Over heates if ac is on
My tata indigo ecs lx TDI gadi kuch problem nahi hai very good car
Bro which obd scanner you used please share the link
Perfect dude! Keep it up 👍 I learned a lot from it, can you please explain more about ECM functions?
Thanks for the comment Sir
Ji ha sir ECU pe seprate video upload karunga jaldi
Meri indica v2 tc obd support karti hai kya obd continue laga k rakh saktey hai kya
Nice video, 👍🏽
Diesel is leaking from my pump! Can you please help.
I'm facing same problem in my car.
What would be best recommended place for car service so that they look into these problems?
Thanks for the comment Sir
Koi bhi mechenic ye setting karna nahi janta hai sahi se
I will recommend you to do it yourself
Super bai , thanks
Thanks for the comment Sir
👍😁😁
Bai maine aap ki help se Apni indica ki milage 4 km /pl jyada bdai
Nice video...............what is the idle rpm for diesel lancer with and without A/C...whether this setting applicable to Lancer also?
Let me check
My car Indica V2 2007 model...ran 2 lakh km..can a setting of diesel pump can be done.....as shown in ur video
Hello, I am using 5pk 730 drive belt in my Indigo ecs cr4 2012 model, what is the right size of belt as my existing belt is making noise .
Thanks for the comment Sir
Please select the belt which fits the pully with edge to edge perfet fitting between pully side teeth and belt without any gap
Then there will be no belt noise
Sir g indica turbo 2007model mein obd lag sakta hai kya
Nice video dude
Meri india vista car me mene setting kri 8mm bolt ki AC on krke kyuki meri car me cut off nhi ho rha tha 8mm bolt ka distance jyada kiya to cut off hone laga lekin AC off krne me RPM bahut km ho rha hai jisse engine off ho jata jb 1st gear pe uthate hai to
Sir plz reply
Thanks for the comment sir
Proper pump setting nahi hua hai
Ap mujhe watsapp pe contact karyea main video call pe setting karwa dunga
@@crackover sir whatsapp no nhi hai mere pass apka
guru y viedo me indigo ecs cr4 engin ka RPM set ho sakta h kya
or y software ki link do
Head m temperature ke switch m 1wire lga hua h socket 2 wire ka h..btao esme 1 hi wire ata h kya ya 2 ate h
Sir meri wali indigo me starting problem hoti hai subha k time dussri self pe start hoti hai mushkil se uske bare batao pls reply me
Projector fogg light tata indigo me laga kr bna dijye vdo sir or door open signal bhi nd open door roof light
Hi bro my indica car was when low fuel on tank it's get rpm goes full down and off and when fuel full it's normal
Meri indigo LS 2003 model hai. Kya usme ye scanner software setting ho sakti hai. Is par video Dal do sir. Isme oil pressure lamp as jata hai uspar bhi video Dal do
Mera ek mechanic setting kiya tha, uske baad gaadi khadi hone ke baad starting problem deta hai, aur start hote hi 1-2 minute tak rpm badha reheta hai... wo tuning setting ke baad se hi ye issue hai... kuchh suggest kar sakte ho @crackover?
Sir can I use 5w40 full synthetic engine oil in my Tata indigo ecs tdi plz plz reply
Thanks for the comment sir yes you can use it.
15w 40 bhai
Tata indica,indigo ka high pressure Pump remove korte waqt kiya kiya chise ka dhiyan dena chahiye iske uper ek video banaye please.
Thanks for the comment sir
Ji sir Maine ek video upload karunga jaldi hi
सार बहुत बहूत अच्छाह hai
Does tata indigo marina tdi 2005 diesel has obd port ?
If yes , Location?
Sir mere pass 2004 non tdi Indigo he jisme 4no injectar me koi wayre nahi he to kya me usme 2008 model indgo ka fi pump bhita sakta hoo or kya who sahi se set ho jaega
Nice
Hi, I have INDICA V2 Ls 2015 model.. mileage only 13-14 on AC.. without ac 14-15 ,. Maximus ac pay Charli hay..
Good, I will try with my car
Best of luck👍😁
Sir pehle bhi comment kiya h.. apne reply ni diya.. mere pas indica V2 non turbo 2007dls model h... usme pump setting kese hoga.... kyu ki ac me pump off ni hora.. try kr liya
Ho sir I need a help from you I drive my Tata indigo ecs in rain and water logging after that my car start making difficult sound and when I turn on ac this sound increase a lot please help me how to solve this problem mechanic near my house told me that timing out ho gai hai please reply
thank youme banbasa se hu mere pas tataindica tdi engine overhaling me kitna kharcha ayega
Thanks 🙏
You’re welcome 😊
Bhai ford ikon Diesel pump pe ek video banado....
having Indigo ecs turbo engine 2016 model with uneven idling, low mileage and lots of black smoke problem. recently serviced the diesel pump and nozzle the smoke emmision reduced now and lost pickup. What would be the problem and how can i get back pick up and Mileage?
Send me the engine sound in wtsap
👌👌👌👌
Hi crackover i have a tata indigo cs 2009 model whenever i put disel in the tank the next day it does not start the disel filter pump get lose
How fix it thanku
Thanks for the comment sir
Can you please tell me that how much oil you always keep in tank
Minimum diesel in the tank.
Also this occurs just after some time or after few hpurs.
I had almost put atmost 2000rs disel
And it does not start after few hours
And air and vapore gets collect in the tank and disel filter pump gets lose
And the air filter horse pipe is also broken
Hello brother rpm check karne ke liye jo apne relay lagai hai wo kaha se milegi
bhai yeh obd scanner tata Indica vista 2013 pr work krega
Thanks for the comment Sir Ji ha bilkul karega
Sar kiya ac on krne pe rediytr fan or kneksn fan dono sat me chlna chahiye kiya
When I ON my Indica V2 car in morning,. 4-5 minutes tak white smoke aara orr sounds be smoth nai hay... 5 minutes kay baad normal hojata.. no smoke and smoth .. so what will be the problem
Bhai tavera car hai morning time let start hori hai or res bhi let horahi hai problem batao please reply just
Tata Indigo ecs lx tdi 2014 ka clutch safety switch bypass kaise Karen????
Sir indigo me p1131 cood cam command value too high bata raha hay kya problem hoga sir
mere vista me gadi khadi ho tab ac bilkul kam nahi karta aur jab gadi chalne lage tab ac kam karta h, mtlab speed me rahega gadi tab sahi kam karta h nahi to kam nahi karta kya prblm ho sakta h....
Hi friend kya a setting tata super ace ko karsak te hai kya bhai
Brother tmse thodi baat krni hai mere paas bhi indigo cs hai 2009 model usme yahi problem hai ho sake to reply krna
My car rfid is work but when the ac is in it is not released after the ac is on it is same can you say me how to set it
Tata indigo cs starting me axlileter dabake chalu karni hoti hai starting struggle de rhi ye problem hai plz suggest me
Sir a setting indica v2 ls bs3 mein kar sakte kya sir.
Thanks for the comment sir
Ji ha
Sir indigo cr4 engine behtar hai ya TDI...Plz suggest
Thanks for the comment sir
Tdi
Tdi indigo pump replacement ka vidio banao sir?
Mere pass indica Vista tdi hai ..engine sound idelpe com jada horahai use kya karna hai
Good afternoon sir please reply me 2007 tata indigo tdi DTC p0222 hai aur throttle pedal normal hai isme sensor nahi hai
Fault code me low voltage ka kuch data show kar raha hai kay
Sir tata indigo ecs tdi 2 lakh se chal gyi h black smoke deti h kya check kraye smoke kam ho jaye
Thanks sir mera car indigo hai engine garam hote hi firing kadak hojata jaise electronic nozzle kaam nai karta iska problem batao badi maherbani hoti apki
Thanks for the comment sir
Sir ap mujhe video bhejyea ki kis tarah ka sound aa raha hai heating hone pe ku ki sound ko bina sune nahi bata paunga ki kay problem hai
@@crackover ok came valv work nai kara to cut cut sound aata hai na same aise hi hai but zyada nai medium ari hai aaj mera mechanic bolra apka pump rooter gaya dalna padega bola aaj new sound aya cr car mai pocha mechanic ko phir ye konsa sound aya mere bhai to mechanic bolra rotet dalo ya pump change karo bolra aap mere saare comments sahi se dhiyan se sunkar reply sir aap great man ho jald hi reply dete ho thanks sir 👌👌👌🙏🙏🙏😘😘😘🙏🙏🙏🙏🙏👌👌👌👌sir apko baar baar msg karke disturb karra. Mujhe maaf kardo sahi se dimagh lagake answer do ye baat ka bora mt manna agar apko galat lagra to maafi chahto apse 🙏🙏🙏🙏🙏
Bhai engine drane aur engine oil treatment per video banao
Hello sir ,, Good information,,
After setting my vehicle ,,,
Rpm is 950 without AC,, and when AC is ON 850 ,,, pressure pump is on and off between 3 to 4 sec,,,
Is rpm settings of vechile is ok ,, any modifications required ??
Please let me know sir,
Sir g. Your RPM should me more when AC is on. Should not less when AC is on.
Obd scanner konsa lena sahi hoga
Hi
Apne kaha ac on karne ke baad rpm set karna hoga taki cut ho and on ho.
But ac off karne ke baad normal rpm kaam hojayega to uska kya?
Thanks for the comment sir
Jab ac on karega to rpm around 1000 ke as pas rehta hai or
Ac off me 800 ke around hona chahiye also
800 rpm optimal rpm hai ideal ke liye
👍💝
tata marina 2009 1.4 tdi chiptuning can it be done ? can u ?
Thanks for the comment Sir yes you can tune the chip but updating is better option than tunning. Also I have no software to tune the chip but you can update it from the service centre
Sir I have manza........ gaadi ek dum se power 6od deti hai bahut jagah dikhaya service centre pe par problem dur nhi ho rhi hai.......Kya aap bta sakte hai kya problem ho sakti hai...
Aur obd 327 manza me kaam krta hai kya
7000493369
Hello dear
Alternator se EGR tak ka air vacuum line troubleshooting kaise kare please do this.
Thanks for the comment Sir
Abhi MAP sensor or MAF Sensor ke video upload karunga uske bad vaccume line ko kaise test karna hai pura iska video dalunga.
Thanks for the suggestion sir.
Bhaia indica v2 dls me vi aisa setting hoga keya? Or pamp auto cut hoga keya? Plz batayega
Yes Bai , maine b kiya , 4 km pl milage bdi
Sir ihave tata venture problem when istart it runs smooth but when i run inspeed no sound but in slow running some sound like tak tak
Thanks for the comment Sir
This sound is coming from engine or from the front part of chasis.
Or when you turn left or right.
Same problem mere hai
Sir 4 no injector ke sensor ke baare me information dijiye
Same question
Hello sir good evening hamara Tata indigo eCS hai subah start hota hai lekin gadi jab 30 se 40 kilometre jata hai tab band karta hun gadi start nahin hoti hai unmen Kya problem hai aap thoda video banaye thank you
Sir scorpio tdi diesel pump ki Bhi proper setting ki video banado
Hello...hamane gadi overall bhi kri lkn abi bhi duwaa detii hai..(TATA superage) us ke mutaliq kcH
Sahi se valve ka ya slip ka kam nahi hua hai