Video není dostupné.
Omlouváme se.
tata indigo high pressure fuel pump setting with ac and milage increase by crackover
Vložit
- čas přidán 25. 02. 2018
- high pressure fuel pump sensors- cam-valve sensor, solenoid-valve sensor & TPS sensor
Hi, I am saourav kumar from #INDIA
In this video, I will tell every thing about engine bay sensors (full working and testing)
*RPM and SPEED (speedometer) sensor location video link- • RPM and SPEED (speedom...
*Fuel injection pump setting video PART-2 link:- • tata indigo fuel injec...
*Fuel-Injection Pump setting Part-1:- • tata indigo fuel injec...
*Tata indigo smoke level at 5000+ RPM video link:- • 5000 RPM no smoke solv...
*Silencer cleaning video link:- • how to remove Black Sm...
*how to clean EGR video ink:- • how to clean EGR with ...
*Facebook page link:- SaouravKumar...
*Tata indigo injection pump setting to get maximum mileage and lowest smoke and high pickup and it helps to tune up the engine and its sound. also helps to reduce black smoke from exhaust and helps to increase engine life.mainly rpm is very difficult to set after 50000km manually but my video will help you. *some extra knowledge:-Primary Functions od IDI engine with ECU:---1. Fuel pump injection timing control.2. Glow plug pre & post heat control.3. EGR system on-off control.Secondary Functions:---1. FICD (Fast Idle Control Device Control). This isthe device whichincreases the rpm when the AC is switched on.2. AC switch off at high Engine temperature and highloading.3. High altitude proportional control.4. Fault detection & storage of trouble codes.The ECU gets its inputs/information about Throttleposition, coolanttemperature, ambient temperature, engine rpm,crankshaft angle & Injectionstart from the following sensors on the engine :1. Throttle Position Sensor or Fuel Level Sensor :This is a potentiometer connected to the fuel delivery lever which isactuated when the acceleratorpedal is pressed. It sends a DC voltage to the ECU which is proportional tothe accelerator position.2. Temperature Sensor: This is a thermistor type ofsensor, monitoring the coolant temp.3. RPM sensor: Part of the alternator. Gives 3voltage pulses for one revolution of the crankshaft.4. Crankshaft Angle Sensor or Crankshaft PositionSensor. This is mounted on the flywheel housing and provides piston TDC (TopDead Centre) information to the ECU, in the form of a number of voltage pulsesper 90 degrees angle of rotation.5. Needle Lift Sensor: This sensor is part of No. 4 cylinder fuel injector,& sends a voltage signal to the ECU at the precise beginning of injection.How it works :Based on the inputs from these sensors, the ECUcontrols the following unitsthrough Relays, Solenoid switches & PWM control :1. Glow Plug Heaters: These are for pre-heating thecylinders. The ECU controls the glow plugs ON time based on ambient &engine temperature.2. Fuel Pump: Injection timing is controlled depending on the position ofthe accelerator pedal----timing is advanced automatically at higher rpm. TheECU controls a cam actuator inside the fuel pump,based on a look-up table stored in the ECU program ROM.3. EGR: This is the Exhaust Gas Recirculationsystem. Part of the exhaustgases is mixed with the air intake to reduce temperatures inside thecylinders to below 210 deg C., which sharplyreduces the formation of Nitrogen Oxides (Nox) in the exhaust, therebyreducing harmful pollutants as reqd. by Euro / BS 2 & 3 norms.The EGR valve iscontrolled by the ECU, & gets activated in the rpm band 1100 to 3000 rpm,with small variations to compensate for engine temp & loading.4. FICD: The fast idle control is used to increasethe idle rpm when the AC is switched on. The ECU activates the FICD through asolenoid switch by monitoring the AC compressor clutch voltage.The ECU also continuously monitors the enginetemperature, & switches off the AC if upper limits are exceeded.All the sensors are also monitored continuously, anda fault or trouble code is stored in non-volatile memory in case of afault, & the Check Engine Light comes ON.
IF THIS VIDEO HELPS YOU DON'T FORGET TO LIKE & SHARE THE VIDEO & ALSO SUBSCRIBE TO MY CHANNEL I film, edit and publish each video on my own. I have had many viewers comment and let me know how I have taught them how to fix their car themselves and save them $$$$ and I love it!thank you.
#TataIndigo #heigh_pressure_fuel_pump sensors#RpmSensor #SpeedometerSensor #TataIndigo #Crackover #crack_over #car_problem #easy #hindi.
Super 1No sir
Thanks for the comment sir
✨❤✌✨✨
@@crackover aa
Bahut hi achha bataya hai , bahut km log jante hai is bare me ....
Ficd la function bahut log nhi jante....
10/10
जय हिन्द जय भारत
Thanks for the comment Sir
😁😁😁👍👍#INDIA
Excellent,really awesome,I tried it.results 100/100. Thank you bro
अनेक अनेक धन्यवाद श्रीमान जी 🙏🙏
Hi, I have found channel is very useful. please include the videos of Tata Safari and Sumo Grande, etc. Changing of Engine oil, gear oil, removing of door inside plastic panel, etc too.
Thank you. Bhai mera same problem hai. Indigo cs 2008 model ka.
Ac sahi nahi chal raha tha , to mechanic ne wo handling thoda badaya tha. Abi ac he band ho gaya hai. Kal wo try karta hu.
Thank you
Thanku for ur video bro from kerala 🤝
Explanation 10/10.
You deserve likes. We have very few Indian CZcamsrs who make DIY videos on cars and you are one of them. Keep up the good work.
11000010:10100100ssAs!N thanks for comment sir .🙏🖒
Crackover your suggestion for the oil separator did help me. Also, I got it installed in my Chevrolet Beat Diesel. Further, thanks for your support through WhatsApp. One last request please keep making videos as they are quite informative and helps a lot in troubleshooting problems without the need of a mechanic.
@@pritamdebnath0903 thanks for the comment Sir
👍👍👍👍😁😁😁
Thanks for valuable information...
Good Video. Keep up the good work. Appreciated
Sir cr4 dicor engine is also same procedure or it will work from commanding from ECU CHIP
Bhai bahut achha samajmai agaya bahut badia tha vedio 👌👌👌👌
Thanks for the comment Sir
😁😁
❤️Thank u so much brother❤️
Aapne jo trick bataya hai ..Jaisa aapne bataya waisa karne par ...Meri car ka problem solve ho gya..
Very very thank u🌷❤️❤️
Thanks for the comment sir
👍😁
Good.
Nice Demo of fuel pump and explanations,good wishes
Ashraf Ahmed thanks for comment sir have a nice day
Your videos are very good. Can you post a video or steps to rectify TATA Indigo Diesel TDI taking self but engine is not starting?
Bhai thanks nice video he
Hi i have replaced my tata indica v2 2005 model engine with indica vista tdi engine. All going good but i think there is some probem . Car is going less speed in higher rpm. For example for reaching 100kmph engine require 3500-3600 rpm in 5th gear. Kindly give some suggestion
Thank u...nice video
bhai ji app ko thanks achhi salah di
Excellent information given by you. Thanks
I need to check my TATA INDICA XETA PETROL sensors, as it has some problems with them. Needs to diagnose which sensor is actually defective. May you help me to solve the issue? Thanks
pawan chohan thanks for comment sir but if please tell me something about problem you are facing in your car ans also how may km you had run and milage
Thank you so much for your kind information
Thanks for the comment sir
😁👍
Very nice video sir
Bhai apki video life saving h .... Knowledge badhati h ....Bhai mere indigo mein start hone pe rpm 10 se upar awaaz karte hue chali jati without acceleration..Aisa kyu ho rha h
DEEPENDER SINGH RAGHAV thanks for comment sir ap thoda ache se pura problem batyea main jaroor help karunga
Thanks bhai nice information make a video on clining of ac cooling coil and ac blower of tata indigocs thanks
Nice video bhai meri Indigo Ki headlight ,a/C or horn bandh hai,relay bhi check ki everything ok what would be the problem.
Bro AAP ka samjhane ka tarika very good h bro indica hi preser pump ke electronic parts ya us me lage sensor ke Naam aur kaise work karta h is ke bare me samjha a ge to aap ka ehsan hoga
Bhai cam wal senser ko alage volteg de sakte he kya mene apani gari Ka pump chenje Kiya he mere pass Tata marina he
Bhai indigo ka injackter leak kr to os problm ko kaise solb kry. Mere indigo ka ek injackter leak kr rha h.
Ap ki video say maine apne car ki shoti moti prolbm solve kr lyta hun. Ap bhut thx
Sir thanks for this video mere bahut kam ka h aap hamesa new video bnaya kare ham sabhi ko aap ke guidance ki jarorat h
Arvind Kumawat thanks for comment sir ji ha bilkul par abhi thodi time ki kami wajh se video nahi bana pata hu par ab regularly upliad karunga video
Good intelinjent
Good video bro
Kya pump se starting problem ho sakti hai morning mei head injector pump ka kaam hua hai pl reply
very good my brother
Nice video . Tepet setting ka video dalo bhai
Very Nice Sir ji
So 👍
thank you
Nice video helpful
Nice video
Good msg bhai
Bhai Tata indigo lx 2004model h Gadi garam hone par self load Nahi Leta battery new lagwai h fir bhi kya problem ho sakti h batao
Brother Nice video! PLZ MAKE A VIDEO TO REPAIR VACCUM PUMP OF TATA INDICA CAR.... My Car's brakes become stiff after driving 20kms and the car loses its pickup... plz throw some light... Thanks
Tata vista tdi me waste gate ko disturb krne se bhi starting me problm aati hai kya but kbhi kbhi aati h humesha nhi aati
Great 👍👍 thanks
Thank you ❤️😊
Good knowledge ....
nice video.. mera indica ev2 tarbo ka piston cheng karne ka kitna kharcha ayega .. sir .. batao sir
Bayya Tata Indica ev2 LS ka.... Speedo meter sensor ka prblm hey ...vooo kidar hothey engine pey
Siyah duman sorunu nedir? Bu yaptıgınız arac rolantisi için dimi
Bhai video keep up the good wark agar video camplit bathanachei peile bathaya badme naei bathaye satig karthe mitarku bi bathanachei bhai parpecttu karsckthe badhme dout niyatha
Mare pass Indica hai 2006 model
Agar uska RPM 800 kare to AC cooling kam ho jati hai kyo ....please replay
My tata indica vista
This is engine noise is very bad so plz suggest me what i can plz
How much distance should the 1st bold must be
Plz reply mene old indica liya he 2007 model or ac chalne me bhut lod leti he or gadi black smoke deti he milege bhi bhut jyda kam he sarvish krvya to pump set karvya to or milege kam ho gya or mere car me valv nhi laga hua hai
Nice video👍
How to connect OBD to our car for checking rpm speed
Nice video dear friend ..
Keep it up & thanks for my help
Bhai mere pass Indica Vista TDI hai usme fuel pump me diesel kase kam jada kiya jata hai ispar par bhi video banaye
Very nice video
Bhai ek video tata cars ke power steering ki hard hone ki problem ko solve krne k liye bhi bnao
Dilver Singh thanks for comment sir ji ha video upload karunga is pe bhi
During starting the car the rpm tends to fluctuate until the engine is warm the car needs to be accelerate in order for the rpm to be constant. Black smoke problem. Do show tips to solve the problem ASAP.
Thank you sir
Thanks for the comment sir
❤✨👍
bhai app ka videos bhote accha hi
ake indca hi
ignition on kartahe AC compressor clutch on hoka off hota.
exlater rase daka chodenama AC compressor clutch off on hotahi
kya hosaktha hi aa problem batayea please.
Potentiometer ko check karwayea or sath me ac ka relay switch bhi check karwayea
ap bahut achaa video m batate h ur apka ka samjhane k tarikaa bahut achaa h ur haa mujhe high presior low paresior k bare m bataye ur kitna hona chahiye gas ki paresior
Ur uske bare m bataye high presoir kitna hona chahiye low paresior kitna hona chahiye
Shaif King thanks for comment sir 40 psi me fuel-pump pump kart hai fuel ko engine me and minimum 36 psi and maximum 43 psi hona chahiye
Crackover thanks bro ur tharmostate sirf cutoff k liye h yaa ur problem k liye lagate h bro
Jaise m poch raha hon ki koi poche mere car m gas kitna h tu kaise maloom chalegaa ki kitnaa gaige m h ur kitna rahena chahiye mnimam ur maxiam
What will do if diesel pressure valve senser leaks via its cable..??
My car indigo marina diesel AC tripping at idle rpm also my rpm needle is fluctuating any suggestion on the issue
Thanks for the comment sir
Try to do high pressure fuel pump setting
This is old video,
One more video is available on fuel pump setting in more detail.
With ficd setting also.
Please check that it will help you.
Bai mojy patia ke heater fan anny time gor sakta ha ku?
Very nice vedio.....I also have the Tata Indigo....I want to suggest you one thing...plz make playlist carwise...your channel will look more sorted.
Alok Singh thanks for comment sir ya i will definitely do it after some days
Sir my indigo TDI diesel rpm drops on ac but ac is doing good cooling. Does some settings is required
Check latest video on fuel pump settings
Bhai kuch dino sey Meri indigo tdi mey start karne per rpm updown hone lagta hai or checkengine light aati hai jab acclater deta hu tab white smoke aati hai fir checkengine light chali jati hai tab theek chalti hai
Agar jaise fan chal raha hai toh car ko bnd krke (key)chabi se fir on krna hota hai jab tak fan bnd nhi hota ja fir fan chalte hi key off krke nikal lehni chaiye plz reply soon
Sir indigo car ki fuel injection me jo nls cable hote ha uske bare me bataiya
Acha video hai sir. Sir meri pass bhi Tata indigo cs hai lekin ish mein start proplem hai shobhe mein start nahi hu para hai sirf chatka mar nesi hi start hota hai toh ish problem ki liye kya karna hoga sir? Aur engine beh bahut julti gharam hojata hai aur ekbar start off kiya toh phir start ho nehi hota hai.. Sir, plz meri mataah kar dejiye na.. Kya karna hoga? Thank you!
Mere car 2015 modal tata indigo TDI hai usame RPM up dwun hote rahta hai kya problem ho sakta hai ?? Bataiye
thanks for comment sir apki gadi ki turbo and exhaust system gnda ho gaya hai ap turbo ko is video ko dekh ke saf kar sakte hai and link is czcams.com/video/k8lFiZiPUuM/video.html but exhaust pipe ko apko kahi khulwa ke pura saf karwana hoga uske bad rpm up down nahi hoga .also video ke description me items ka link diya hua jiska maine use kiya hai ap le sakte hai.
bhai tata sumo dicor engine ka injector lock ko kase nikal sakate hai without Scan tool ke alava plz ans me ok
Please tata indigo CS ka clutch pedal setting kr liye bhi 1 video banaaye
Super video
Bro meri indica 90 par jatke
Mar ti haa. 90 c uper pickup.
Drop hoti Haa. And black smoke
Mrti haaa. Plese reply
sir , i have a indigocs car have a two issue phased in which
one is black smoke and another during push the execletter but speed not increase
narendra sharma thanks for comment sir please clean exhaust pipe and turbocharger it will definitely boost performance.
Bro indigo running my off hojathi hi pir 10 min kay bat pir star hogi kay problem hai bro
Sir meri tats indigo sx 2007 tdi h. Ac higher rpm (1500 approx.) par chalu hota h. Ac wale Kahe rahe the Ki fcid kaam nahi kar raha to kay fcid se ac chaoo hota h
Nice video
Mere pass Indica vista hai usme AC proper work ni krta hai local traffic me jb chalate hai to cooling continue nhi krta jisse cooling nhi ho pati or highway pe jb continue ek speed pe chalti hai car to proper cooling krta hai continue
Plz solution bataye
Thanks for the comment sir
8mm bolt ka distance thoda kam karyea jara sa
Meri indica car hai.
Right hand se 2nd wala high pressure line k nut me se diesel leak ho rha hai thoda thoda toh kya usse khol k ander rubber ki seal laga k tight karne se leak band ho jaega?? Ya pir naya kharidna padega or naya kitne ka aega andaz se?
Piplani me pump ka setting kaha pe hoga ?
Super bro
Nice video dost
Sir meri car check engine dikha rhi aw pls app bta skte kya problem hai or check engine ka light kese jaye ga pls reply me?
thanks for comment sir check light kafi sare reasons se ati hai usko check karne ka ek hi tarika hai ki OBD2 ELM 327 se check karyea
Good job 👍👌
Thanks for the comment Sir
😁😁👍👍👍
Hi .. mere pas Tata indica v2 2009 model he sir..
Usme Whit smoke nikalta he or RPM loo.down hota he to me Kay karu ..... ??
Hi, mai potentio meter ko change Kar chuka Hu, so Lorena CM Reyna chaihiye
How much Centimeter should be adjust for the lever.
Sir ye inline pump hai ki rottary pump bataye please.
indica may 4no nozzle ka kya roll hai or high pressure pump me jo swich hai wo kiss liye hai
Thanks for comment sir injectors ko hi nozzle kehte hai and ye diesel ko spray karne me help karte hai and potentiometer AC ko ON-OF karne me help karta hai
Hi brother mera gaadi indica V2 ...2015 model mai tabh ac on on karthahu thabi rpm badega pickup kam. Hoga .... diesel mechanic ko bathaya but huno ac compressor load lera bolre but i muje kuch solution dejiye bhai.
Sir indigo dicor gadi hai Gadi grum hone k bad pickup low hojata hai or bich bich me band ho jati hai thandi rhne k badd aisa nhi hota Jab ac vgire chalu ho or gadi jyda chlti to signal pr vgire band hojati hai acha performance nhi deti and servcing krte waqut mistri ko kya kya krne ko bolna chiye iske liye plz reply
Thanks bro .
Thanks for the comment sir Ji
😁🙏😀
Meri ritz me ac on karne par engen ki sound bhot bad rahi he kya problem ho sakta he
Hi mere pas indigo es 2012 model hai. Car Summer sesion me bhi morning me start hone me problem karti hai aur bahut vibration hota engine me. Kya ho sakta hai.
Pristine Materials thanks for comment sir agar jayda self le raha hai to pump se oil kam kiya hua hai but agar pump se air nikalne ke bad engine chalu ho raha hai to apki gadi ka pump me jo air releasing valve hai wo kharab ho gaya hai ap usko change karwayea sahi ho jayega .and engine jayda vibrate kar raha hai without accelerator to pump se oil kam kiya hua hai usko badhane se sahi ho jayega
hello bhai
mere pass indiad v2 hi us me vo wire vale setting nahi hai ac vali, meri car me problem hi ki vo jsb hum us ko 2nd gear mi chla rhe hi bina race deye vo apne app over speed ho jati hi,uski speed fast ho jati hi. to vo diesel pump me hi problem hi or kasse thek hogi ?
Narinder Singh thanks for comment sir ap apna watsapp no de dijyea main apko contact karunga
Bhai gadi ki headlight cleaning ki video banado
Ac intake ko saaf krke apne ac ko naya bnane wali video bnao pls..
ťèçhñíçķ an modification thanks for comment sir Abhi dekhta hu time milta hai to upload karunga
Sir please is carka rediyatar fan ka wayring relly ka total video banao carnt kaha se ATA hai aur relly kaise Kam karta hai uska 1video banao
bhaiya meri Tata Indica DLS
2 dafa engine banaya
aur ek dafa hed setting karwaya
engine me troctor jaisi awaaz aanay lagi
Thanks for the comment sir
Ap ek bar cam valve sensor ko check karyea
Sir mere pass v indigo cs 2009 hai sir jab me gaddi satart krta hu to to rpm ki speed normal rehti hai 3-4mint gaddi statr rehne par rpm ki speed bad jati hai or jitna time gaddi chalti hai to rpm ki speed bdi rehti hai to sir kya problem hai battai muje