Fuel Pump and Sender Unit - Volkswagen Golf Mk5
Vložit
- čas přidán 28. 07. 2024
- How to remove and replace the fuel pump and sender unit on a 2004 to 2007 Volkswagen Golf Mk5 with the 1.4 litre petrol engine. The part number is 1K0919051M. Working with fuel or fuel components can be extremely hazardous so please take precautions by wearing proper protective gear and having an appropriate fire extinguisher at the ready.
Here's a video showing how to depressurize the fuel system:
• Video
Thanks for watching. Please comment, like and subscribe !.
All of my uploaded material is protected under copyright law. None of my videos may be re-uploaded, reproduced or transmitted, in part or in full, in any form or by any means, without the written permission of the copyright holder.
© / screwsnutsandbolts 2020
Read important information below:
Disclaimer
Under no circumstances will Screwsnutsandbolts be responsible or liable in any way for any content, including but not limited to, any errors or omissions in the content, or for any loss or damage of any kind incurred as a result of any content communicated in this video, whether by Screwsnutsandbolts or a third party. In no event shall Screwsnutsandbolts be liable for any special, indirect or consequential damages or any damages whatsoever resulting from loss of use, data or profits arising out of or in connection with the availability, use or performance of any information communicated in this video. Due to factors beyond the control of Screwsnutsandbolts, it cannot guarantee against improper use or unauthorized modifications of this information. Screwsnutsandbolts assumes no liability for property damage or injury incurred as a result of any of the information contained in this video. Use this information at your own risk. Screwsnutsandbolts recommends safe practices when performing any do it yourself repairs and or with tools seen or implied in this video. Due to factors beyond the control of Screwsnutsandbolts, no information contained in this video shall create any expressed or implied warranty or guarantee of any particular result. Any injury, damage, or loss that may result from improper use of these tools, equipment, or from the information contained in this video is the sole responsibility of the user and not Screwsnutsandbolts. - Auta a dopravní prostředky
Here's a video showing how to depressurize the fuel system: czcams.com/video/C4B5G1vzH3c/video.html
what happen if you didnt make that mark
Was taken this from a 2004 golf Tue 2 1 2023 could not get the wires off pipes your video spot on mate David...in Ennis County Clare Ireland your a great help cheers ..... up the Raaaa
Thank you. This was very helpful.
You're very welcome !
Excellent clear video, thank you 🙏
You're very welcome
Excellent video , very helpful to me
Thanks for watching !
Great video! Thanks
You're welcome!
Great video !
Thanks!
Felicitări pentru postare
Thanks !
Very usefull video!
Thanks for watching !
هل مضخة البنزين تركب في سيارة ديزل
Thank you
You're welcome
why the arrow should be pointed towards the rear of the car?
Hey cheers for the video, does this have to be coded when a new one is in?
No I don't think so
Is there a need to do any adaptation of the new fuel pump? I'm asking for the Golf MK5 GTI
No I don't think so, but Im not 100% sure to be honest
Thanks for this. I did the same test with my replacement. Works out of the tank. Inside the tank, doesnt work. It did once, then dropped to zero as I was about to move off. Maybe I installed the pump the wrong direction. However my Polo 1.2 TSI 2015 does not have any markings which line up with anything outside. There are only two arrows on the pump one points to one outlet R which I assume is return. The other 'V' which points at the side of the pump but what on earth does V mean. Vorne? Which is front in German. Could you offer any help please? Car starts and runs fine, just showing empty. Also I can get the float to work in the tank but so far from the pipes for a connection. Makes no sense.
Are you sure you have the correct replacement part, did you measure it up to the old one ?
My electrical connector was too hard to get off lol. Broke the red tab. Pain in the ass.
Yeah they're fiddly little parts to work with
Same. I'm going to attempt to change mine tomorrow. Fabia diesel. Same set up.
Thanks for the video. I am getting a p2540 code. Is it probably a bad fuel pump? I have changed already the cam follower, the low fuel pressure sensor and the fuel pump module? Thanks in advance
A bad fuel pump is one possibility.
Can you think of any other problem, in order to take a look? @@screwsnutsandbolts
Hi there,have that same code too,replaced the cam follower and low pressure fuel sensor. Now noticed my hard starts in the morning I have to leave the key on for 10 seconds to get a quick start. Otherwise it just cranks if I don't. Thanx to this man's video ill replace my fuel pump soonest.
hello, I have a golf 5 1.9 105 bkc engine, I have a problem, it made a short circuit and there is no light on the board, it starts and the second second it stops, can you help me?
I can't, sorry. You'll probably have to have a mechanic take a look at it.
So when the gas reading aren't correct in the instrument cluster this is what needs to be replaced?
A faulty sender unit is certainly one possibility.
Merci 👍
You're welcome !
Does the fuel pump have a filter on it and can it be replaced?
The fuel filter is usually under the car near the fuel tank as shown in this video: czcams.com/video/xIGvV5NCneo/video.html
Can the pump be changed separately ?
Yes you can disassemble the sender unit and change the pump
هل من الممكن تركيب مضخة البنزين على سيارة ديزل
I think they are different but I'm not 100% sure
🙏merci 👍
You're welcome !
Is P0089 engine light code?
It's one possibility: www.yourmechanic.com/article/p0089-obd-ii-trouble-code-fuel-pressure-regulator-1-performance-by-spencer-clayton
Hi, what kind if engine is that? 1k1 BCA?
I'm not sure, I don't have the car anymore, sorry.
Yes BCA
can you plz tell me what are the symptom of bad pump?
Check this website: www.friendlychev.com/blogs/3756/6-common-signs-of-a-faulty-fuel-pump
Whey you open betray
To remove the risk of an electrical spark igniting the fuel vapour as you work on the pump.
I hate that electric plug on the fuel pump lol
Lol. Some of them can be difficult to remove. This one wasn't too bad :)
@@screwsnutsandbolts that's why I hate them hahahaha